Ford Excursion Problem Report
Ford Excursion Rough Idle Caused By EGR Sensor Sticking
Intermittent rough idle may be caused by the EGR sensor sticking, causing the EGR valve to stay slightly open. Our technicians tell us the valve and sensor must be replaced together to correct this concern.
Pull wire plug off egr valve. remove two bolts that hold it in. remove egr valve with "crows foot (Tool" Grab with crows foot on edge of egr valve. Pry slowly. Be carful not to damage both o-rings. Clean all carbon off valve. Start engine and spray good carb cleaner or spray brake clean in egr valve hole and hold gas peddle at 2500 -3000 rpm, until exhaust is clean (one can). put some high temp grease on o-rings and replace. This will help for about a year. I Haven't decided what I am going to do next - Visitor
I have owned my 2005 Ford Excursion Limited Edition (Diesel 6.0L) truck since 11/2006 with one prior owner. Although it has a little over 100,000 miles, it has constantly been in the shop due to a sticky EGR valve sticking. I have paid a large sum of money to my Ford Dealership and is constantly told "this should fix the problem once and for all." Well, it's in the shop again for the same problem....I have seen other Ford Truck drivers on side the road with black smoke coming from the exhaust...an all too familiar site. Called Ford regarding a recall that I noted on the internet site (safecar.gov) and found where a recall was issued in July 2005. (Ford Recall # 05S34) After inquiring with a Ford representative...well wouldn't you know it...no such recall has ever exsisted. That figures, just made me realize its time to get rid of it....and never buy any Ford products again. I have owned several Ford vehicles in the past and husband drives one also F350. I will never buy another vehicle made from this company AGAIN!!!!! - Visitor
Can not locate EGR , no tube running from exhaust manifold and no DFPE on throttle body. Have a...
The EGR cooler may leak internally, causing white smoke from the tailpipe.
where is the egr valve located on the engine?
when i first start it wont idle but when it warms it will only idle at about 500 rpm there is a...
Engine runs rough, doesn't seem to have full power, exhaust smells funny, and tail pipe is blac...