2000 Mercury Mountaineer Recalls
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Ford has recalled certain 1998-2002 Explorer, Explorer Sport Trac, and Mercury Mountaineer vehicles for an issue with the driver's seat recliner mechanism. The upper bolt that attaches the recliner mechanism to the seat back frame could fracture. If this happens, the seat back could fall backward and disrupt the driver, possibly causing an accident. Dealers will replace the upper bolt and, on some vehicles, replace a lower bolt as well.
Ford has recalled certain 1999-2001 Explorer, Explorer Sport Trac, and Mercury Mountaineer vehicles for a possible binding speed control cable. If the cable binds, throttle return could be affected, causing a sticking accelerator. Dealers will inspect the cable and replace it if necessary.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Ford has recalled Firestone Wilderness AT and Radial ATX tires installed on multiple lines of Ford trucks from 1991 to 2000. On some tires, under extreme conditions, the tread could separate, which can cause immediate tire failure. This may lead to a loss of vehicle control, injury, and death. Dealers replaced the affected tires.
Ford has recalled certain 2000 Explorer and Mercury Mountaineer vehicles equipped with side air bags for a possible problem with the side crash sensors. If the seat belt webbing is forcibly extracted from a locked retractor with a jerking motion, the side crash sensors could command deployment of the side air bags with the key in the run position. Dealers will replace the side crash sensors with a revised sensor.
Ford has recalled certain 1999-2000 Explorer and Mercury Mountaineer vehicles with 4.0L engines and all-wheel-drive for a concern with the generic electronic module (GEM). The module may lock up, causing multiple electronic functions such as wiper operation, lighting operation, and 4-wheel-drive operation to malfunction. This could create a safety hazard and possibly lead to a crash. Dealers will install a resistor in the GEM module circuit.