1992 Ford Explorer Recalls
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
Ford has recalled Firestone Wilderness AT and Radial ATX tires installed on multiple lines of Ford trucks from 1991 to 2000. On some tires, under extreme conditions, the tread could separate, which can cause immediate tire failure. This may lead to a loss of vehicle control, injury, and death. Dealers replaced the affected tires.
Ford has recalled 1991-1993 Explorers equipped with a removable sunroof. In some cases, the sunroof panel can separate due to improper hinge engagement. The sunroof could fall on vehicle occupants, causing distraction and possible safety issues. Dealers will provide owners with usage instructions for the sunroof and a warning label to install by the sunroof latch knob detailing proper installation procedures.
Ford has recalled certain 1992-1994 Explorer vehicles for a concern with the mirror control switch. In some cases, the mirror control switch could short circuit, resulting in smoke or a fire. Dealers will install an in-line 10 amp fuse in the positive battery feed to the switch.
Ford has recalled 1991-1994 Explorer and Ranger trucks because the bolts that mount the master cylinder to the brake booster may fracture. If these bolts fracture, brake loss could occur. Dealers will replace the power brake vacuum booster assembly.
Ford has recalled certain 1991-1995 Explorer vehicles for a concern with the liftgate gas lift brackets. In some cases, the liftgate gas lift bracket may separate from the liftgate, causing the liftgate to possibly fall. Dealers will reinforce the bracket attachments for the liftgate lifts.
Ford has recalled certain 1992-1993 Explorer vehicles for a concern with the liftgate hydraulic lift brackets. In some cases, the bracket weld could fracture, resulting in the liftgate falling, which could cause injury. Dealers will install reinforcement brackets.