» » »

Car Recalls

Recalls are issued for cars with safety-related defects or problems

2004 BMW 530i recalls

 

Electrical & Lights, March 23, 2012

RepairPal Expert Overview:

The insulated connector for the positive battery cable may have been incorrectly attached to the trunk floor panel, which can lead to a loosening of the bolt connection. Loosening of the connection can cause an increase in electrical resistance and overheating of the cable connection, which could lead to a fire, even when the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been completed. Dealers will secure the battery bolt cable connection as necessary to correct this concern.

 

Learn more »

Body, Interior & Misc., December 14, 2004

RepairPal Expert Overview:

Excessive wear may develop on the side bolsters of the seat backrest. As a result, the seat heater mat located in this area may be damaged. If such damage were to occur, with the system turned on, the occupant may feel excessive heat from the area. The heating element may damage or melt a small hole in this damaged area of the seat cover. If this happened, it could lead to the seat occupant being burned. Dealers will modify the seat heating circuit to correct this concern. This recall is expected to begin during December of 2004.

Learn more »

Engine, July 16, 2004

RepairPal Expert Overview:

The digital management control (EMC) unit may not have been produced according to specification. The engine may stall and not restart. As a result, a loss of power steering, and after repeated actuation of the brake pedal, a loss of brake power assist will occur. These conditions could result in a vehicle crash. Dealers will install a new (EMC) unit to correct this issue. This recall began on July 16, 2004.

Learn more »

Engine, July 5, 2004

RepairPal Expert Overview:

A circular retention clip at the quick-release fuel line coupling was inadvertently not installed. In the event of a severe frontal crash, the quick release coupling could separate, causing fuel leakage. Any fuel leak always increases the risk of a fire. Dealers will install a retention clip at the quick-release coupling on the fuel supply line. The recall began on July 5, 2004.

Learn more »

Body, Interior & Misc.

Summary: BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.

Learn more »
Ask a Question