finding campaignWWP-99for the Cooling System Conditioner

I have the info, but unfortunately it includes some picture format, which won't be displayed here. If you post an e-mail I can send you the whole thing. Campaign - Engine Cylinder Head Coolant Leaks NUMBER: WWP-99 DATE: 02/2004 APPLICABILITY: 2000-2002MY Subaru Legacy and Outback; 1999-2002MY Impreza; 1999-2002MY Forester SUBJECT: Engine Cooling System Conditioner INTRODUCTION Subaru of America, Inc. (SOA) has determined that over time, affected vehicles may develop small external coolant leaks at engine cylinder head gaskets. This is the result of normal expansion and contraction of engine components caused by the heating and cooling of these parts. To prevent cylinder head gasket leaks from developing or to correct existing leaks, a special Subaru Cooling System Conditioner should be added to affected vehicle cooling systems. This Service Program will involve adding one bottle of Genuine Subaru Cooling System Conditioner to the engine cooling system. AFFECTED VEHICLES 2000-2002 MY Subaru Legacy and Outback with 2.5L engine. 1999-2002 MY Impreza with 2.5L engine. 1999-2002 MY Forester with 2.5L engine. Affected vehicles are identified in the VIN range chart below. Only vehicles with a 2.5L engine are affected. NOTE :Prior to performing repairs, confirm coverage for potentially affected vehicles by using the Vehicle Coverage Inquiry in the Dealer Communication System (DCS). Vehicles identified in the preceding chart may include VINs that were not distributed in the U.S. market. Dealers will be provided a list of VINs that include the owner name and address. This information will enable dealers follow-up with owners of potentially affected vehicles. These listings contain owners names and addresses obtained from State Motor Vehicle Registration Records. The use of such motor vehicle registration data for any other purpose is unlawful. Accordingly dealers are urged to limit the use of this listing only for the purpose of completion of this service program. OWNER NOTIFICATION SOA prepare and mail an Owner Notification Letter to owners of the affected vehicles. Because of the number of vehicles affected and parts availability, owner notification will occur on or about the dates listed in the following four stages. 1999 MY - February 16, 2004 2000 MY - March 1, 2004 2001 MY - April 1, 2004 2002 MY - May 3, 2004 A copy of the owner notification letter is included at the end of this bulletin. OWNER REIMBURSEMENT FOR PREVIOUS REPAIRS Owners are being advised in the owner notification letter, found at the end of this bulletin, that if they have previously paid an authorized Subaru dealer for repairs related to this Service Program, they may be entitled to reimbursement. The owners are further advised, to qualify for any reimbursement they must submit the original repair invoice to Subaru of America, Inc. Please review the owner notification letter, which explains this procedure so that you are familiar with it, and can assist owners with any questions. FUTURE MAINTENANCE In the future, it will be necessary to add Genuine Subaru Coding System Conditioner to the coding system of affected vehicles whenever the engine coolant is replaced. As a reminder, owners will be sent update pages with their notification letter that instructs them to add the pages to their Owner's Manual and Warranty and Maintenance Booklet Except for the initial application associated with this campaign, the cost of adding the conditioner is the owner's responsibility. CYLINDER HEAD GASKET WARRANTY EXTENSION For owners of affected vehicles that have this Service Program performed promptly, SOA is extending coverage under the Subaru Limited Warranty for cylinder head gasket external coolant leaks to a period of 8 years or 100,000 miles, whichever occurs first Warranty coverage begins on the date the vehicle was delivered to the first retail purchaser. If the vehicle was used as a demonstrator or company vehicle before being sold at retail, warranty coverage begins on the date the vehicle was first placed in such service. As a further condition for this extended warranty coverage to apply, the owner must properly maintain the vehicle's cooling system in accordance with the recommended maintenance schedule and Genuine Subaru Cooling System Conditioner must be added each time the engine coolant is replaced. Resulting damage caused by a lack of maintenance or low coolant level will not be covered. Replacement of the Cooling System Conditioner during inspection and maintenance services is not covered under warranty. DEALER PROGRAM RESPONSIBILITY Dealers are to promptly service vehicles subject to this Service Program at no charge to the vehicle owner regardless of mileage, age of the vehicle, or ownership. For affected vehicles sold after the date on the dealer's computer list, dealers are to contact those owners and provide them with a copy of the owner notification letter. They should also arrange to make the required correction according to the instructions in the service procedure section of this bulletin. Vehicles in Dealer Inventory Dealers are also to promptly perform the applicable service procedures defined in this bulletin to correct affected vehicles in their inventory (new, used, demo). Additionally, whenever a vehicle subject to this Service Program is taken into dealer new or used inventory, or is in the dealership for service, necessary steps should be taken to ensure the Service Program correction has been made before selling or releasing the vehicle. New or used vehicles listed in a recall/campaign that are in dealer stock must be: ^ Immediately identified. ^ Tagged or otherwise marked to prevent their delivery or use prior to inspection and/or repair. ^ Inspected and/or repaired in accordance with instructions outlined in the Product Campaign Bulletin. Any Authorized Subaru Dealer failing to perform the applicable service procedures defined in this bulletin to correct affected vehicles in their inventory (new, used, demo) prior to the vehicle being placed in service may be in breach of the Subaru Dealer Agreement. PARTS INFORMATION Subaru Cooling System Conditioner Note :Subaru Cooling System Conditioner is packaged in cases that contain 12 bottles. Each affected vehicle requires one (1) bottle. Each case contains enough material to treat 12 vehicles. Prior to the release of this Service Program, each dealer will automatically be shipped a quantity of Subaru Cooling System Conditioner equivalent to 40% of their vehicle sales, or up to a maximum of 20 cases. Additional quantities of the Cooling System Conditioner will be available through normal parts channels after 2/15/04. In order to maintain an adequate part supply, SOA requests that Dealers only order quantities necessary to satisfy anticipated demand. REPAIR PROCEDURES The repair procedure involves adding Subaru Cooling System Conditioner to the cooling system. Follow the recommended procedure that applies to either a "Cold" or "Hot" engine. Caution :The engine cooling system is under pressure and may he extremely hot. To prevent personal injury or vehicle damage he sure to take appropriate precautions while performing this procedure. Service Procedure on a COLD Engine NOTE :Impreza and Forester vehicle system components are shown in the images below, but Legacy and Outback models are similar. Consult your service manual for exact locations and illustrations. Zee