Estimates last updated October 16, 2025

2005 Lincoln Navigator AC Compressor Replacement Cost

The average cost for a 2005 Lincoln Navigator AC Compressor Replacement is between $669 and $901.

Labor costs are estimated between $171 and $251 while parts are priced between $498 and $651.
This range does not include taxes and fees, and does not factor in your unique location. Related repairs may also be needed.

AC Compressor Replacement

What is an AC compressor?

The air conditioning compressor moves refrigerant through the AC system and compresses low-pressure refrigerant to create high-pressure refrigerant.

How does the AC compressor work?

The serpentine belt or drive belt runs the AC compressor, allowing it to pressurize refrigerant and pass it on through the system. The compressor also uses check valves and other moving parts that allow refrigerant to flow in one direction.

What are the symptoms related to a bad AC compressor?

When the compressor fails, the most common symptom is warm air from the vents. A squealing or grinding noise may also be heard from the compressor in the event of mechanical failure.

Can I drive with an AC compressor problem?

In most cases, a vehicle with a bad air conditioning compressor is safe to drive. However, if grinding is heard from the compressor pulley, bearing failure may occur, causing the serpentine belt to come off. If this occurs, the battery warning light will illuminate, and the engine will stall due to lack of electrical power.

How often do AC compressors need to be replaced?

Failure of the air conditioning compressor is common because moisture or clogs in the system will place stress on the compressor. Compressor clutch failure is much more common on older vehicles. In general, AC compressors tend to fail after 60,000 to 70,000 miles, but that time may vary depending on use, demand and operating conditions.

Lincoln AC Compressor Replacement Cost Estimates

The average cost for a AC Compressor Replacement is between $669 and $901 but can vary from car to car.

Lincoln Navigator AC Compressor Replacement Cost by Year

The average cost for a Lincoln Navigator AC Compressor Replacement is between $669 and $901 but can vary from car to car.

2022 Lincoln Navigator

$1,313-$1,462

2021 Lincoln Navigator

$1,556-$1,833

2020 Lincoln Navigator

$1,556-$1,833

2019 Lincoln Navigator

$1,556-$1,833

2018 Lincoln Navigator

$1,556-$1,833

AC Compressor Replacement

Jump to:Commonly associated repairs Related OBD codes Cost estimates by vehicle Cost estimates by year

What is an AC compressor?

The air conditioning compressor moves refrigerant through the AC system and compresses low-pressure refrigerant to create high-pressure refrigerant.

How does the AC compressor work?

What are the symptoms related to a bad AC compressor?

When the compressor fails, the most common symptom is warm air from the vents. A squealing or grinding noise may also be heard from the compressor in the event of mechanical failure.

Can I drive with an AC compressor problem?

How often do AC compressors need to be replaced?

How are AC compressor issues diagnosed?

Diagnosing the compressor requires advanced knowledge of air conditioning systems. AC systems should be repaired by a technician with proper training and certification. Professional-grade equipment is used to read the pressure, and the technician must rely on hours of classroom and training to diagnose the faulty part.

How is an AC compressor replaced?

Replacement of most air conditioning components requires the complete evacuation of the air conditioning system. The serpentine belt, refrigerant lines and electrical connectors must be removed. Finally, the mounting bolts and hardware must be removed to let the compressor come free from the engine. A new compressor will then be installed, all parts will be put back in place, and the AC system will be recharged with refrigerant.