This limited regional recall is for vehicles currently registered or first sold in southern Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. Upon deployment the passenger airbag inflator could rupture, increasing the risk of personal injury. Dealers will replace the passenger side air bag inflator to correct this concern.
Acura RL Recalls
This limited regional recall is for vehicles currently registered or first sold in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico and the U.S. Virgin Islands, and equipped with Takata-brand air bag inflators. Upon deployment the passenger airbag inflator could rupture, increasing the risk of personal injury. Dealers will replace the affected airbag inflator modules to correct this concern.
The Vehicle Stability Assist (VSA) system is designed to help keep the vehicle from skidding if the driver tries to round a corner too quickly. This is achieved by applying the brake at one or more wheels as necessary. During the manufacturing process an electrical capacitor in the VSA control module may have been damaged. This can cause intermittent minor application of the brakes or if the driver were to apply the brakes while the VSA is malfunctioning, the vehicle may come to an abrupt stop. Additionally, due to a loose electrical ground connection, on certain 2005 Pilots the VSA system may unexpectedly apply partial brake force without illumination of the brake lights. Sudden inadvertent braking, especially without illumination of the brake lights, may increase the risk of a crash. Dealers will install a partial wiring harness containing a capacitor for the VSA system, the affected Pilots models will have their ground connection tightened.
Use of incorrect brake fluid may cause a rubber seal in the rear of the master cylinder to become dry and leak. The leaking fluid will enter the brake booster and may not be visible externally. A loss of brake fluid can reduce braking efficiency, increasing the risk of a crash. Dealers will replace the affected seal on all master cylinders, leaking or not. This recall is scheduled to begin during December of 2010. The Acura recall number is R52; the Honda Recall Number is R51.
Honda has recalled 2005 Accord, Odyssey, Acura RL, TL, TSX, and 2006 Ridgeline models because the fuel pump relay may fail. This can prevent the fuel pump from operating, which may cause the engine to stall or not start. Dealers will replace the fuel pump relay.
Honda has recalled 2006 Accord, Civic, CR-V, Element, Insight, Odyssey, Pilot, Ridgeline, Acura MDX, RL, RSX, TL, TSX, and 2007 Honda Fit vehicles because the contact information for the National Highway Traffic Safety Administration (NHTSA) is listed incorrectly in the owner's manual. Honda is contacting dealers and customers to provide them with a postcard containing the correct information.
The brake system master cylinder may corrode internally. This may result in poor braking performance and lengthened stopping distances, which can cause an accident. Dealers will replace the master cylinder assembly.
Acura is recalling certain 2000–2002 TL vehicles due to possible brake light switch failure, which is caused by assembly oil contaminating the electrical contacts. The brake lights may not illuminate when the brakes are applied, increasing the risk of a crash. Dealers will clean excess oil from the brake pedal assembly and replace the brake light switch.
Acura is recalling certain 1996–1998 TL and 1996–1999 RL models because an automatic transmission case bolt may loosen and fall out, allowing the transmission to disengage from the differential. This may cause a loss of power to the drive wheels without warning. Also, a parked vehicle could move unexpectedly if the parking brake is not set. Dealers will install a redesigned transmission case bolt to correct this issue.