Close

Volvo S60 Problems

Find the most common issues based on Volvo S60 owner complaints.
Tap theto learn more about the most common Volvo S60 problems.

Most Common Volvo S60 Problems

The automatic transmission may develop shifting problems and/or the Check Engine Light may illuminate due to internal component failure and/or software issues. It is always best to be sure the tran...
It is not uncommon for the exterior light bulbs to burn out prematurely. No repair option has been reported other than replacing the failed bulb.
Front upper strut mounts may wear prematurely, resulting in loud noise from the front of the vehicle when going over bumps.
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Looking for a particular Volvo S60 problem?

2 Known Volvo S60 Brakes Problems

The anti-lock brake system (ABS) warning light and/or other dash warning lights may illuminate due to a failed ABS Control Module. Replacement of the failed module is generally required to correct ...
There have been reports of a failed ABS Control Module causing the ABS and Check Engine warning lights to illuminate. Repair or replacement of the failed module will be required to correct this issue.

5 Known Volvo S60 Drive Train Problems

The automatic transmission may develop shifting problems and/or the Check Engine Light may illuminate due to internal component failure and/or software issues. It is always best to be sure the tran...
Several complaints have been reported regarding Volvo S60 transmission shifting issues. Long shift times between gear shifts, hard shifting, hard downshifting and a loss of transmission operation...
The turbocharger return pipe seal may develop an oil leak. The leak can begin very small, but will eventually progress into a large leak. Our technicians recommend having this repaired at first s...

6 Known Volvo S60 Electrical & Lights Problems

It is not uncommon for the exterior light bulbs to burn out prematurely. No repair option has been reported other than replacing the failed bulb.
There is a computer that controls all these items and it's called the rear electrical module, or the "REM". To temporarily address this issue you can pull the fuse from the rear fuse box labeled "R...
The steering wheel module (SWM) stops working, this affects the turn signals, horn, cruise control, and audio buttons on the steering wheel.

5 Known Volvo S60 Engine Problems

The Electronic Throttle Module (ETM) has a higher than normal failure rate. Volvo has extended the warranty on some of the ETMs to 10 years/200,000 miles
As the vehicle ages, the plastic end tanks on the radiator may crack and cause a coolant leak. Because of the placement of the radiator, the leak may not be visible in the engine bay or underneath ...
Coolant leaking from the front of the vehicle is often due to a leaking radiator, which must be replaced.

3 Known Volvo S60 Exhaust & Emissions Problems

Mass airflow sensor (MAF) failures have been reported, causing engine idle problems, as well as acceleration hesitations. The Check Engine Light will normally illuminate when the MAF starts to fail.
The MAF sensors are prone to failing and turning on the Check Engine Light.
The mass air flow (MAF) sensor may fail, resulting in drivability issues and/or illumination of the Check Engine Light.

0 Known Volvo S60 Heating & Air Conditioning Problems

0 Known Volvo S60 Maintenance Problems

0 Known Volvo S60 Miscellaneous Problems

4 Known Volvo S60 Suspension & Steering Problems

Front upper strut mounts may wear prematurely, resulting in loud noise from the front of the vehicle when going over bumps.
Front and/or rear sway bar end links may wear out prematurely, causing a knocking noise from the front or rear of the vehicle when driving on bumpy roads. Our technicians recommend inspecting the...
The front control arm bushings wear out, resulting in alignment issues and squeaking and/or knocking noises from the front end. Worn bushings will require replacement.

28
Known Volvo S60 Problems & Complaints

The automatic transmission may develop shifting problems and/or the Check Engine Light may illuminate due to internal component failure and/or software issues. It is always best to be sure the tran...
The Electronic Throttle Module (ETM) has a higher than normal failure rate. Volvo has extended the warranty on some of the ETMs to 10 years/200,000 miles
The MAF sensors are prone to failing and turning on the Check Engine Light.
One or both of the front wheel bearings may fail resulting in a rumbling noise from the front wheel area when driving over 25 mph.
The turbocharger return pipe seal may develop an oil leak. The leak can begin very small, but will eventually progress into a large leak. Our technicians recommend having this repaired at first s...
The front control arm bushings wear out, resulting in alignment issues and squeaking and/or knocking noises from the front end. Worn bushings will require replacement.
Front upper strut mounts may wear prematurely, resulting in loud noise from the front of the vehicle when going over bumps.
Several complaints have been reported regarding Volvo S60 transmission shifting issues. Long shift times between gear shifts, hard shifting, hard downshifting and a loss of transmission operation...
The 6-speed automatic transmission used in the 2006-2016 Volvo S60 is known for issues with harsh shifting, especially while the transmission is slightly warmer than normal operating temperature. ...
The mass air flow (MAF) sensor may fail, resulting in drivability issues and/or illumination of the Check Engine Light.
There is a computer that controls all these items and it's called the rear electrical module, or the "REM". To temporarily address this issue you can pull the fuse from the rear fuse box labeled "R...
Mass airflow sensor (MAF) failures have been reported, causing engine idle problems, as well as acceleration hesitations. The Check Engine Light will normally illuminate when the MAF starts to fail.
There have been reports of a failed ABS Control Module causing the ABS and Check Engine warning lights to illuminate. Repair or replacement of the failed module will be required to correct this issue.
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Researching a Volvo S60?
Get maintenance costs, reviews, recalls and more.