Close

2002 Acura RL Problems

RepairPal has identified the most common problems with the 2002 Acura RL based on complaints from actual vehicle owners. We'll tell you what the problem is and what it'll take to fix it.

No car image 94a1663db56199c5353592009e34aaa51078a2469bed068bb8d6f0ba43accf97
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
7
Known Problems

The Check Engine Light may illuminate due to an EVAP system fault. Commonly this is caused by the failure of one of the EVAP control valves.

The exhaust recirculation valve (EGR) on the 1996-2012 Acura RL may fail, causing:

  • Illumination of the check engine light
  • OBD trouble codes P0401 and P1491
  • Rough idle
  • Reduced fuel economy
  • Engine vibrations
  • Hesitation or stalling
  • Long cranking before engine starts
  • Failure of state or federal smog tests
  • The EGR valve has open and closed positions, and opens or closes on command from the computer.

    Exhaust gases constantly pass through the valve when it is open, leaving carbon deposits on the valve. These carbon deposits may lead the the valve sticking in the open or closed position.

    To correct this issue, sometimes it is sufficient to clean the valve, but replacement is recommended in all cases.

    For further information on your vehicle's issue, try out our diagnostics tool here.

    The Airbag (SRS) warning light may illuminate due to one or more failed sensors. Our technicians recommend complete diagnoses of any stored fault codes because these sensors can be very expensive to replace.

    The 1999-2004 Acura RL has brake caliper issues, which are known for causing vibration and grinding noises at all times.

    The brake rotor is a disk that sits between two brake pads. The brake pads are squeezed against the disk by what is called a brake caliper. When that caliper gets stuck, the brake pads are permanently pressed against the rotor causing:

  • Vibration in brake pedal
  • Vibration on steering wheel
  • Illumination of the ABS or brake warning light
  • Grinding noise from one corner of the vehicle
  • Vehicle pulls to one side of the road
  • Braking requires more pressure on the brake pedal
  • The repair for a seized brake caliper, the brake pads, brake rotor, and brake caliper must be replaced or vibration will remain after the new caliper is installed. Changing the brake fluid and flushing the brake system according to manufacturer specified intervals can help improve longevity of the brake caliper.

    The 1996-2006 Acura RL may have issues with the fuel pump and fuel injection relays.

    These relays send power to the fuel pump and fuel injectors when the key is turned to the “ON” position. So, when they fail, there is no electrical current to the necessary fuel system components to send fuel into the engine, causing engine stalling or failure to start.

    In this situation, there are many other possibilities, so testing components is vital for time and money savings.

    If the relays test bad, they must be replaced with relays specific for that circuit.

    To help prolong the life of your under-hood electrical components, ensure the lid for the fuse block is closed, and any factory sealing material is correctly installed.

    The starter motor used on the 1996-2006 Acura RL frequently fails on vehicles around 125,000 miles.

    It may help prolong the life of the starter to service the starter to ensure the connections are clean and tight at the 100,000 mile mark.

    Acura extended the warranty due to numerous issues with the automatic transmission. Problems with the automatic transmission may make the car undrivable and can result in costly repairs.