Close

2002 Ford F-250 Super Duty Problems

RepairPal has identified the most common problems with the 2002 Ford F-250 Super Duty based on complaints from actual vehicle owners. We'll tell you what the problem is and what it'll take to fix it.

No car image 94a1663db56199c5353592009e34aaa51078a2469bed068bb8d6f0ba43accf97
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
9
Known Problems

The Ford F-250 Super Duty has known issues with the V8 engine ejecting spark plugs. This will make a tapping or knocking noise, plus the engine will begin to misfire at all speeds. The check engine light will also illuminate.

The threads on the cylinder head are too short and soft, allowing pressure from combustion to overwhelm and destroy the threads. 

When the spark plug ejects, the cylinder head becomes damaged, necessitating repair of the spark plug port threads, or replacement of the cylinder head and cylinder head gasket. 

Ford has recommended a method of repair for the cylinder head that prevents the spark plug from ejecting under future use. Replacement of all spark plugs is not necessary, but an updated spark plug design can help prevent this from happening in the future. 

There is a technical service bulletin for the V8 engine.

The high pressure diesel fuel injection pump may fail, resulting in a "no start" condition.

A defective idler pulley and / or belt material can cause a chirp or squeak noise from the engine area on initial start up. The idler pulley and / or belt will need to be replaced with revised parts.

An oil leak may develop from the the right side head gasket.  Oil from this type of leak will commonly drip onto the starter. Our technician tell us an updated head gasket is available to correct this concern.

If the engine cranks but will not start, this may be caused by damaged wiring to the high pressure fuel pump. Wiring to the pump can be chafed, which causes the pump to stop working. The chafed wires will need to be accessed and repaired.

Delamination of the diesel fuel tank can occur resulting in a loss of power due to debris clogging the fuel filters. In some cases the fuel injection pump and/or fuel injectors have also been damaged. Ford has issued a service bulletin (#19728) addressing this concern.

An illuminated Check Engine Light could indicate that one or more of the ignition coils has failed due to excessive spark plug gap. To fix this problem, the ignition coils that have failed, the spark plugs, and all coil boots should be replaced.

Using the correct oil for this engine is critical. Improper engine oil can foam in the high pressure system and not develop enough pressure for operation. Symptoms of this can be hard starting, long cranking time before start, rough engine idle, and a lack of power. Another sign is tiny bubbles in the oil on the engine oil dipstick after the engine is shut off. The additives in the correct oil that protect against foaming can still break down, so changing the oil at the correct intervals is important.