Problem Reports
Problem with your car? See what our experts say or submit your own.
1999 BMW 540i Problems
Multiple Parts May be Recommended to Correct Coolant Loss
Leaks are known to develop in the cooling system. It is common to see more than one part recommended for repair/replacement due to overlapping labor and the use of many plastic parts in the system.
Engine Oil Leaks
Engine oil leaks commonly develop from both valve cover gaskets, intake manifold, and PCV plate after about 60,000 miles.
Loss of Power Steering Fluid Due to Leaking Hoses
A fluid leak may develop from one or more power steering hose. When a leak is being repaired, it is not uncommon for multiple hoses to be replaced.
Blower Final Stage Fan Resistor May Fail
The blower final stage fan resistor is known to fail. Symptoms are the heater fan speed varies regardless of the setting, the fan will not turn off when the car is switched off, or the fan will not switch on at all.
Noise From Top of Front/Rear Doors When Windows Are Fully Up
A creak or squeak can be heard from the top of the front or rear doors. This noise is most noticeable when the windows are fully up. The noise is caused by the decay of the flocking material on the door seals. New door seals, Teflon tape, special lube, or a combination of all of these may be needed to eliminate the noise.
Alignment/Tire Wear Issue Due to Worn Rear Lower Ball Joints
The rear lower ball joints may wear causing alignment and tire wear issues as a result of the excessive play in these joints. Our technicians tell us a 4wheel alignment should be performed after ball joint replacement.
Loosness in the Front Suspension Due to Worn Tension Strut Bushings
The front thrust rod bushings—also referred to as tension strut bushings—are known to fail occasionally. The oil-filled rubber mounts weaken and crack over time, causing a mushy road feel and shuddering in the steering wheel when going over bumps. These worn bushings should be replaced.
Cars passanger floor gets very wet when raining or going through the car wash.
When driving in the rain or going threough the car wash the rear interior floor gets very wet and water acumulates on the floor.
It seems the drainage system from the sides and or sunroof is not working or is clogged.
Is it a big job to fix ?
Thank you,
George