Because of issues with the glow plugs and/or the glow plug wiring harness from the control relay, the Check Engine Light may illuminate. Our technicians tell us there is a service bulletin, not a recall from Volkswagen regarding replacement of the glow plugs on 2004-2005 model years only.
Problems for specific Volkswagen Jetta TDI years:
Car problem reports
Problem with your car? See what our experts say or submit your own.
Newest reported 2009 Volkswagen Jetta TDI problems
Heater core leaks are common in this model, more so if the wrong anti-freeze/coolant is used in the cooling system.
Reverse gear failures and noise in the manual transmission models are common.
One or both head lights may not work due to premature head light bulb burnout and/or bulb harness failure. Care should be taken to inspect the head light harness connector for damage when replacing bulbs. Damaged connectors should be replaced.
Electrical issues that are difficult to diagnose—and sometimes intermittent—are typically due to ground wiring issues. The most troublesome ground locations are under the battery or at the engine.
Condensation in the heater case may cause a musty odor from the heating, ventilation and AC (HVAC) system after sitting for two hours or more. Our technicians tell us that a cleaner is available for the heater case and the drain system should be checked for debris.
drains battery because electric fan does not shut off. Dealer replaced fan free of charge due to recently out of warranty.
Oil and carbon tend to build up, creating restrictions in the intake manifold. Symptoms will be loss of power (sometimes severe) and poor fuel economy.
Shifting issues due to internal problems in high mileage automatic transmissions can be difficult to resolve without transmission replacement.
One or more power windows may fail. Our technicians tell us this is commonly due to a failed window regulator which will require replacement.
Rear door drivers-side. When using Keyless entry doors won't lock. The door above is culprit. All others lock. A short alarm sounds when all doors are locked. Presently no alarm sounds. Any suggestions for a fix. By the way I did use my second clicker which is brand new. Therefore battery is new.