Close

1991 Toyota Corolla Problems

Find the most common issues based on 1991 Toyota Corolla owner complaints.
Tap theto learn more about the most common 1991 Toyota Corolla problems.

Most Common 1991 Toyota Corolla Problems

At higher mileages, (125,000-150,000) the automatic transmission may not shift correctly. This can be caused by the throttle position sensor being out of adjustment or a shift solenoid needing to b...
If the engine will not crank over, the most common problem is the starter. These will tend to go out at about 100,00-125,000 miles. Sometimes it is only the starter solenoid, but often the comple...
The ignition coil inside the distributor may fail. Our technicians tell us this may result in a hesitation on acceleration, especially when the vehicle is warming up on cold, rainy days. The pick...
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Looking for a particular 1991 Toyota Corolla problem?

1 Known 1991 Toyota Corolla Brakes Problem

Front brake rotors can wear causing a pulsation felt in the brake pedal. Our technicians tell us this condition is best corrected by replacement of the front rotors and brake pads.

3 Known 1991 Toyota Corolla Drive Train Problems

At higher mileages, (125,000-150,000) the automatic transmission may not shift correctly. This can be caused by the throttle position sensor being out of adjustment or a shift solenoid needing to b...
On vehicles with a manual transmission, worn shift bushings can cause the transmission to pop out of gear, especially when coasting down in 1st or 2nd gear. Replacing all the shift linkage bushin...
You may be able to prevent automatic transmission problems by servicing the transmission and inspecting the fluid every 30,000 miles. If the fluid is dark or burned, the transmission system should ...

1 Known 1991 Toyota Corolla Electrical & Lights Problem

If the engine will not crank over, the most common problem is the starter. These will tend to go out at about 100,00-125,000 miles. Sometimes it is only the starter solenoid, but often the comple...

5 Known 1991 Toyota Corolla Engine Problems

The ignition coil inside the distributor may fail. Our technicians tell us this may result in a hesitation on acceleration, especially when the vehicle is warming up on cold, rainy days. The pick...
The engine mount on the passenger side of the car can wear out on cars with high mileage. This will put extra stress on the other mounts and the faulty mount will need to be replaced.
A loss of power on the freeway may due to an internally leaking fuel pulsation dampener. This commonly occurs on higher mileage vehicles.

2 Known 1991 Toyota Corolla Exhaust & Emissions Problems

The EGR System tends to get restricted or blocked with carbon after 100,000- 125,000 miles which will cause an emissions test failure for NOX. If the EGR system is equipped with an EGR temperat...
Over the time the exhaust gas recirculation (EGR) system may become plugged with debris, the oxygen sensor may also be getting slow or 'lazy' around this time. When servicing or cleaning the EGR ...

1 Known 1991 Toyota Corolla Heating & Air Conditioning Problem

Usually by 150,000 miles the AC system will need some attention, especially in climates where it is used often. Our technicians tell us that it is best to service the AC system every 2-3 years. T...

1 Known 1991 Toyota Corolla Maintenance Problem

Brake fluid can become dirty and may cause problems in the brake system; it should be flushed every 60,000 miles.

1 Known 1991 Toyota Corolla Miscellaneous Problem

By 100,000 miles the ignition key tends to wear out and should be replaced or it may not work as well in the door locks or ignition switch.

3 Known 1991 Toyota Corolla Suspension & Steering Problems

If the vehicle develops an annoying, clunking sound when driving over bumps it is usually the struts and strut bearing plates. These may need replacing at 100,000-125,000 miles or sooner. If the ...
The power steering pump and power steering hoses tend to develop leaks and require replacement.
A squeak or groan noise may be noted from the front or rear suspension. Spraying a light lubricant on the suspension bushings 1-2 times per year may help eliminate the problem.

18
Known 1991 Toyota Corolla Problems & Complaints

The ignition coil inside the distributor may fail. Our technicians tell us this may result in a hesitation on acceleration, especially when the vehicle is warming up on cold, rainy days. The pick...
At higher mileages, (125,000-150,000) the automatic transmission may not shift correctly. This can be caused by the throttle position sensor being out of adjustment or a shift solenoid needing to b...
A squeak or groan noise may be noted from the front or rear suspension. Spraying a light lubricant on the suspension bushings 1-2 times per year may help eliminate the problem.
On vehicles with a manual transmission, worn shift bushings can cause the transmission to pop out of gear, especially when coasting down in 1st or 2nd gear. Replacing all the shift linkage bushin...
If the vehicle develops an annoying, clunking sound when driving over bumps it is usually the struts and strut bearing plates. These may need replacing at 100,000-125,000 miles or sooner. If the ...
The EGR System tends to get restricted or blocked with carbon after 100,000- 125,000 miles which will cause an emissions test failure for NOX. If the EGR system is equipped with an EGR temperat...
If the engine will not crank over, the most common problem is the starter. These will tend to go out at about 100,00-125,000 miles. Sometimes it is only the starter solenoid, but often the comple...
Front brake rotors can wear causing a pulsation felt in the brake pedal. Our technicians tell us this condition is best corrected by replacement of the front rotors and brake pads.
Usually by 150,000 miles the AC system will need some attention, especially in climates where it is used often. Our technicians tell us that it is best to service the AC system every 2-3 years. T...
By 100,000 miles the ignition key tends to wear out and should be replaced or it may not work as well in the door locks or ignition switch.
Over the time the exhaust gas recirculation (EGR) system may become plugged with debris, the oxygen sensor may also be getting slow or 'lazy' around this time. When servicing or cleaning the EGR ...
A loss of power on the freeway may due to an internally leaking fuel pulsation dampener. This commonly occurs on higher mileage vehicles.
Brake fluid can become dirty and may cause problems in the brake system; it should be flushed every 60,000 miles.
You may be able to prevent automatic transmission problems by servicing the transmission and inspecting the fluid every 30,000 miles. If the fluid is dark or burned, the transmission system should ...
The engine mount on the passenger side of the car can wear out on cars with high mileage. This will put extra stress on the other mounts and the faulty mount will need to be replaced.
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Researching a 1991 Toyota Corolla?
Get maintenance costs, reviews, recalls and more.