Water or oil may enter into the ignition coil cover and the spark plug bore, causing a misfire and illuminating the Check Engine Light. A coil with improved water and oil sealing is available and should be installed.
Problems for specific Ford Thunderbird years:
Car problem reports
Problem with your car? See what our experts say or submit your own.
Repairpal verified Ford Thunderbird problems
The composite (plastic) intake manifold may crack near the thermostat housing and cause a coolant leak. Ford released an updated manifold that was reinforced to prevent a recurrence. No recall was issued for this problem but Ford did extend the warranty to seven years on some models from the date of purchase.
If you experience difficulty starting the engine when cold, stalling at idle, or hesitations during acceleration, it may be the idle air bypass valve. This valve helps the vehicle idle steady when the accelerator pedal is not pressed.
While steering, if you hear a clunk or a rattle, or if you experience premature tire wear, this could indicate the inner tie rod ends are loose or worn and will require replacement.
The battery light may illuminate on the instrument panel because the alternator wire harness connector is damaged. A new connector kit is available and should be installed to correct this concern.
There may be an extended warranty on the ignition coils - see your Ford Dealer for more information-Thanks John B for this information!
For the 2.3L 4 Cylinder and 5.0L V8 engine, the electrical ignition switch poses a fire hazard. An updated switch is available.
Engine misfire could be caused by worn or broken motor mounts that raise the motor on one side while the vehicle is accelerating. The stress on the engine control wiring harness can cause breaks in the injector or sensor wires, which then causes drivability concerns such as poor fuel economy and engine misfires.