Close

1996 Plymouth Grand Voyager Problems

Find the most common issues based on 1996 Plymouth Grand Voyager owner complaints.
Tap theto learn more about the most common 1996 Plymouth Grand Voyager problems.

Most Common 1996 Plymouth Grand Voyager Problems

One or more power windows may stop working due to a failed window motor or regulator. In some cases these items are replaced as a set. If not, diagnoses will be required to determine which is at fa...
On higher-mileage vehicles, engine oil leaks from the valve covers and front crankshaft seal are common.
Illuminated of the airbag warning light may be caused by a lost connection between the clockspring (behind the steering wheel) and the steering wheel-mounted electrical components. Other steeri...
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more

Common 1996 Plymouth Grand Voyager Repair Estimates

Looking for a particular 1996 Plymouth Grand Voyager problem?

3 Known 1996 Plymouth Grand Voyager Brakes Problems

While driving through deep or blowing snow/water, moisture may enter the rear brake drums, causing rust to develop on the rear brake drum and shoe friction surfaces. Over time, repeated (and someti...
When braking during low speeds (under 10 MPH), the brake pedal may vibrate and the ABS hydraulic unit may cause a rumbling noise. This is caused by a momentary loss of the wheel speed signal to the...
Caused by the parking brake actuator lever(s), AWD-equipped vehicles may experience a rattle in the area of the rear wheels. Installing a foam isolator on each parking brake actuator lever will fix...

3 Known 1996 Plymouth Grand Voyager Drive Train Problems

A delay in the transaxle engagement (greater than three seconds) may have multiple causes, including a defective pump, defective internal lip seals, valve body components, park-reverse-neutral-dr...
AWD equipped vehicles can show a wide range of transmission problems, often caused by using the wrong-sized and/or mismatched tires. Be sure that all the tires are the same and that all four are ...
A defective vehicle speed sensor can cause problems with the cruise control and speedometer operation, as well as erratic shifting. The connectors on the sensors are also susceptible to corrosi...

6 Known 1996 Plymouth Grand Voyager Electrical & Lights Problems

Illuminated of the airbag warning light may be caused by a lost connection between the clockspring (behind the steering wheel) and the steering wheel-mounted electrical components. Other steeri...
A malfunctioning switch in the steering column can cause the front windshield wipers to self-activate or not turn off. A failed windshield switch will require replacement.
If the door lock actuators (integrated into the door latch assembly) are noisy and/or not working, the latch should be replaced. For some model years, the actuator for the sliding door is available...

7 Known 1996 Plymouth Grand Voyager Engine Problems

On higher-mileage vehicles, engine oil leaks from the valve covers and front crankshaft seal are common.
Oil leaks at the valve cover gaskets and cam plugs at the rear of the cylinder heads are common.
A dirty throttle body may cause low engine idle speed or frequent stalling, as oily residue blocks air flow in the throttle when the throttle is closed. Throttle body cleaning may be necessary to...

0 Known 1996 Plymouth Grand Voyager Exhaust & Emissions Problems

2 Known 1996 Plymouth Grand Voyager Heating & Air Conditioning Problems

The auxiliary heater hose connections (that are routed to the rear heater under the vehicle) can develop coolant leaks.
Some vehicles may develop a musty odor coming from the HVAC system, Dodge has issued a cleaner/disinfectant and a coating for the evaporator designed to inhibit bacterial growth.

0 Known 1996 Plymouth Grand Voyager Maintenance Problems

6 Known 1996 Plymouth Grand Voyager Miscellaneous Problems

One or more power windows may stop working due to a failed window motor or regulator. In some cases these items are replaced as a set. If not, diagnoses will be required to determine which is at fa...
Hood misalignment, cowl cover misalignment, wiper module drain tube(s), and/or the lower plenum drain hose may cause the HVAC housing to leak water onto the passenger side floor. Diagnoses will be ...
Intermittently, the key may not start the car or release from the ignition. If it is excessively worn, replace the key. If the new key doesn't work, replacing the lock cylinder including tumblers...

4 Known 1996 Plymouth Grand Voyager Suspension & Steering Problems

During turning, squeaks can come from the strut area; the strut mount assembly should be replaced.
If a "honk" noise occurs during low-speed parking lot maneuvers, replace the power steering lines and/or power steering rack and perform revised procedures to bleed the system.
A momentary loss of power steering can occur when the AC or defroster is on during high humidity conditions. This is due to condensation from the evaporator draining onto the serpentine belt. To f...

31
Known 1996 Plymouth Grand Voyager Problems & Complaints

On higher-mileage vehicles, engine oil leaks from the valve covers and front crankshaft seal are common.
Carbon buildup on the top of the piston is common. As the buildup increases with mileage and over time, symptoms vary from light ticking, to ticking/hammering, to hammering/knocking noises. Fuel in...
Spilling beverages around the cup holder may cause the lid to stick or bind. To fix the problem, remove and wash the cup holder with dishwashing soap and water and apply lubricant to the sliding me...
A dirty throttle body may cause low engine idle speed or frequent stalling, as oily residue blocks air flow in the throttle when the throttle is closed. Throttle body cleaning may be necessary to...
A defective vehicle speed sensor can cause problems with the cruise control and speedometer operation, as well as erratic shifting. The connectors on the sensors are also susceptible to corrosi...
One or more power windows may stop working due to a failed window motor or regulator. In some cases these items are replaced as a set. If not, diagnoses will be required to determine which is at fa...
Some vehicles may develop a musty odor coming from the HVAC system, Dodge has issued a cleaner/disinfectant and a coating for the evaporator designed to inhibit bacterial growth.
During turning, squeaks can come from the strut area; the strut mount assembly should be replaced.
Hood misalignment, cowl cover misalignment, wiper module drain tube(s), and/or the lower plenum drain hose may cause the HVAC housing to leak water onto the passenger side floor. Diagnoses will be ...
Illuminated of the airbag warning light may be caused by a lost connection between the clockspring (behind the steering wheel) and the steering wheel-mounted electrical components. Other steeri...
A malfunctioning switch in the steering column can cause the front windshield wipers to self-activate or not turn off. A failed windshield switch will require replacement.
A momentary loss of power steering can occur when the AC or defroster is on during high humidity conditions. This is due to condensation from the evaporator draining onto the serpentine belt. To f...
If you hear a popping, clunking, or snapping sound from the front of the vehicle after five miles of driving on smooth surfaces, the outer tie rod ends may be worn and require replacement.
When braking during low speeds (under 10 MPH), the brake pedal may vibrate and the ABS hydraulic unit may cause a rumbling noise. This is caused by a momentary loss of the wheel speed signal to the...
Timing cover oil and coolant leaks are common, the oil and coolant don't normally mix. Our technicians recommend to replace the timing chain and cam sprocket if the timing cover is removed to resea...
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Researching a 1996 Plymouth Grand Voyager?
Get maintenance costs, reviews, recalls and more.