Close

1991 Dodge D250 Problems

Find the most common issues based on 1991 Dodge D250 owner complaints.
Tap theto learn more about the most common 1991 Dodge D250 problems.

Most Common 1991 Dodge D250 Problems

Carbon buildup on the top of the piston is common. Over time this can lead to symptoms varying from light ticking to knocking noises. Performing a fuel injector cleaning procedure can often h...
The powertrain control module (PCM) may fail resulting in a lack of AC cooling. The lack of cooling could be caused by evaporator freeze-up due to the AC compressor staying on continuously or conve...
Oil leaks from the valve cover gaskets, timing cover gasket, distributor o-ring, and rear main seal area are common. The leak at the rear main seal area is generally not the seal itself but the be...
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more

Common 1991 Dodge D250 Repair Estimates

Looking for a particular 1991 Dodge D250 problem?

1 Known 1991 Dodge D250 Brakes Problem

Vehicles equipped with 12" diameter rear brakes may encounter premature rear brake shoe wear. If it is found that the brake system is functioning as designed the repair would be to replace the aff...

2 Known 1991 Dodge D250 Drive Train Problems

Carbon buildup on the top of the piston is common. Over time this can lead to symptoms varying from light ticking to knocking noises. Performing a fuel injector cleaning procedure can often h...
Pinched or restricted transmission oil cooler lines can cause transmission failure due to lack of lubrication. Our technicians recommend complete inspection of the transmission cooler and lines i...

1 Known 1991 Dodge D250 Electrical & Lights Problem

A condition may develop where the fuel gauge reads empty with too much fuel still in the fuel tank. Our technicians tell us that installing a new wire harness that provides a common ground for th...

2 Known 1991 Dodge D250 Engine Problems

Oil leaks from the valve cover gaskets, timing cover gasket, distributor o-ring, and rear main seal area are common. The leak at the rear main seal area is generally not the seal itself but the be...
Moderate to severe engine damage may result from using non-DaimlerChrysler approved oil filters. Our technicians tell us that the neoprene compounds used in the manufacture of the unapproved filter...

2 Known 1991 Dodge D250 Exhaust & Emissions Problems

Engines using a throttle body fuel injection system may develop a fuel leak from the fuel injector nozzle or the injector o-ring seal can cause any of the following: Hard starting, rough idle, blac...
Diesel engines may develop a hard start or no start condition due to any one of the following issues: Low fuel pressure, air entering the fuel system, and loss of fuel system prime. Our technician...

4 Known 1991 Dodge D250 Heating & Air Conditioning Problems

The powertrain control module (PCM) may fail resulting in a lack of AC cooling. The lack of cooling could be caused by evaporator freeze-up due to the AC compressor staying on continuously or conve...
The fuse may blow repeatedly for the HVAC blower motor or the motor may stop working all together. Our technicians tell us that can often be repaired by replacing the blower motor switch with a ...
The blower motor may operate erratically and the blower switch operation has a sticky or mushy feeling, the detents almost non existent. Our technicians tell us that the blower switch should be r...

0 Known 1991 Dodge D250 Maintenance Problems

1 Known 1991 Dodge D250 Miscellaneous Problem

Cracking or popping sounds from the cowl area may be a result of cowl cracks at the lower corners of the windshield. The fenders must be removed to see the cracks. If cracks are found, a rein...

0 Known 1991 Dodge D250 Suspension & Steering Problems

13
Known 1991 Dodge D250 Problems & Complaints

The fuse may blow repeatedly for the HVAC blower motor or the motor may stop working all together. Our technicians tell us that can often be repaired by replacing the blower motor switch with a ...
The blower motor may operate erratically and the blower switch operation has a sticky or mushy feeling, the detents almost non existent. Our technicians tell us that the blower switch should be r...
The AC/heater (HVAC) system may unexpectedly switch to the defrost mode when accelerating. This system is operated by engine vacuum and should be inspected for any vacuum leaks if this problem d...
Oil leaks from the valve cover gaskets, timing cover gasket, distributor o-ring, and rear main seal area are common. The leak at the rear main seal area is generally not the seal itself but the be...
The powertrain control module (PCM) may fail resulting in a lack of AC cooling. The lack of cooling could be caused by evaporator freeze-up due to the AC compressor staying on continuously or conve...
Engines using a throttle body fuel injection system may develop a fuel leak from the fuel injector nozzle or the injector o-ring seal can cause any of the following: Hard starting, rough idle, blac...
Diesel engines may develop a hard start or no start condition due to any one of the following issues: Low fuel pressure, air entering the fuel system, and loss of fuel system prime. Our technician...
Moderate to severe engine damage may result from using non-DaimlerChrysler approved oil filters. Our technicians tell us that the neoprene compounds used in the manufacture of the unapproved filter...
Pinched or restricted transmission oil cooler lines can cause transmission failure due to lack of lubrication. Our technicians recommend complete inspection of the transmission cooler and lines i...
Carbon buildup on the top of the piston is common. Over time this can lead to symptoms varying from light ticking to knocking noises. Performing a fuel injector cleaning procedure can often h...
Vehicles equipped with 12" diameter rear brakes may encounter premature rear brake shoe wear. If it is found that the brake system is functioning as designed the repair would be to replace the aff...
Cracking or popping sounds from the cowl area may be a result of cowl cracks at the lower corners of the windshield. The fenders must be removed to see the cracks. If cracks are found, a rein...
A condition may develop where the fuel gauge reads empty with too much fuel still in the fuel tank. Our technicians tell us that installing a new wire harness that provides a common ground for th...
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Researching a 1991 Dodge D250?
Get maintenance costs, reviews, recalls and more.