Close

1992 Chevrolet Suburban 2500 Problems

Find the most common issues based on 1992 Chevrolet Suburban 2500 owner complaints.
Tap theto learn more about the most common 1992 Chevrolet Suburban 2500 problems.

Most Common 1992 Chevrolet Suburban 2500 Problems

Power brake systems using "hydro-boost" may leak power steering fluid from the hydro-boost unit located behind the brake master cylinder. Replacement of the hydro-boost unit is the common repair to...
The anti-lock brake system (ABS) front wheel speed sensors are prone to failure. When a sensor fails, the ABS warning light may illuminate and/or the ABS system may activate erratically.
The fuel pump may fail causing the engine to stall and not restart. Our technicians recommend replacing the fuel filter every 30,000 miles to help prevent undue strain on the fuel pump.
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more

Common 1992 Chevrolet Suburban 2500 Repair Estimates

Looking for a particular 1992 Chevrolet Suburban 2500 problem?

2 Known 1992 Chevrolet Suburban 2500 Brakes Problems

Power brake systems using "hydro-boost" may leak power steering fluid from the hydro-boost unit located behind the brake master cylinder. Replacement of the hydro-boost unit is the common repair to...
The anti-lock brake system (ABS) front wheel speed sensors are prone to failure. When a sensor fails, the ABS warning light may illuminate and/or the ABS system may activate erratically.

1 Known 1992 Chevrolet Suburban 2500 Drive Train Problem

On the 4L80-E Transmission (Diesel and 7.4L gas engine), Transmission fluid may leak through the electrical connector on the side of the transmission, damaging the wire harness and causing the tra...

1 Known 1992 Chevrolet Suburban 2500 Electrical & Lights Problem

The windshield wipers may not work intermittently due to a faulty wiper motor control board. Our technicians tell us that lightly taping on the wiper motor when the fault occurs should temporarily ...

5 Known 1992 Chevrolet Suburban 2500 Engine Problems

The fuel pump may fail causing the engine to stall and not restart. Our technicians recommend replacing the fuel filter every 30,000 miles to help prevent undue strain on the fuel pump.
The intake manifold gasket may develop and external engine oil or coolant leak. In some cases, an internal coolant leak may occur causing coolant to mix with the engine oil. Running the engine wit...
A coolant leak may develop from the water pump. The engine may overheat as a result of the coolant loss. A leaking water pump should be replaced.

0 Known 1992 Chevrolet Suburban 2500 Exhaust & Emissions Problems

3 Known 1992 Chevrolet Suburban 2500 Heating & Air Conditioning Problems

One or more heater & AC (HVAC) air delivery and/or temperature mode door actuator may fail. This can result in incorrect air delivery or temperature. If this occurs, fault code(s) stored...
The air conditioning compressor may develop an abnormal noise and require replacement. Our technicians tell us that whenever a compressor is being replaced for a noise condition, a filter kit shoul...
The quick-connect fittings for the heater hoses tend to leak engine coolant. This problem commonly occurs because the metal housing has become brittle, which can break and cause leaks.

1 Known 1992 Chevrolet Suburban 2500 Maintenance Problem

Our technicians recommend flushing the brake fluid every 60,000 miles. Brake fluid that is dirty may cause problems in the brake system.

2 Known 1992 Chevrolet Suburban 2500 Miscellaneous Problems

The inside and outside door handles are prone to breaking.
The power door lock actuators may become slow to operate or stop working completely and require replacement.

0 Known 1992 Chevrolet Suburban 2500 Suspension & Steering Problems

15
Known 1992 Chevrolet Suburban 2500 Problems & Complaints

Power brake systems using "hydro-boost" may leak power steering fluid from the hydro-boost unit located behind the brake master cylinder. Replacement of the hydro-boost unit is the common repair to...
The air conditioning compressor may develop an abnormal noise and require replacement. Our technicians tell us that whenever a compressor is being replaced for a noise condition, a filter kit shoul...
The distributor may develop internal faults. This can cause a rough running engine or stalling condition, the Check Engine Light may or may not illuminate. Our technicians tell us that the distribu...
The quick-connect fittings for the heater hoses tend to leak engine coolant. This problem commonly occurs because the metal housing has become brittle, which can break and cause leaks.
The windshield wipers may not work intermittently due to a faulty wiper motor control board. Our technicians tell us that lightly taping on the wiper motor when the fault occurs should temporarily ...
An engine vacuum leak may develop from the throttle body gasket causing a higher than normal idle speed. Failed gaskets should be replaced.
The fuel pump may fail causing the engine to stall and not restart. Our technicians recommend replacing the fuel filter every 30,000 miles to help prevent undue strain on the fuel pump.
The power door lock actuators may become slow to operate or stop working completely and require replacement.
A coolant leak may develop from the water pump. The engine may overheat as a result of the coolant loss. A leaking water pump should be replaced.
The intake manifold gasket may develop and external engine oil or coolant leak. In some cases, an internal coolant leak may occur causing coolant to mix with the engine oil. Running the engine wit...
The inside and outside door handles are prone to breaking.
One or more heater & AC (HVAC) air delivery and/or temperature mode door actuator may fail. This can result in incorrect air delivery or temperature. If this occurs, fault code(s) stored...
The anti-lock brake system (ABS) front wheel speed sensors are prone to failure. When a sensor fails, the ABS warning light may illuminate and/or the ABS system may activate erratically.
On the 4L80-E Transmission (Diesel and 7.4L gas engine), Transmission fluid may leak through the electrical connector on the side of the transmission, damaging the wire harness and causing the tra...
Our technicians recommend flushing the brake fluid every 60,000 miles. Brake fluid that is dirty may cause problems in the brake system.
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Researching a 1992 Chevrolet Suburban 2500?
Get maintenance costs, reviews, recalls and more.