Close

1997 Chevrolet Suburban 1500 Problems

Find the most common issues based on 1997 Chevrolet Suburban 1500 owner complaints.
Tap theto learn more about the most common 1997 Chevrolet Suburban 1500 problems.

Most Common 1997 Chevrolet Suburban 1500 Problems

The power door lock actuators may become slow to operate or stop working completely and require replacement.
One or more heater & AC (HVAC) air delivery and/or temperature mode door actuator may fail. This can result in incorrect air delivery or temperature. If this occurs, fault code(s) stored...
The front or rear differential may develop an abnormal noise due to worn bearings or another internal fault. Our technicians tell us that a complete overhaul of the affected differential is com...
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Looking for a particular 1997 Chevrolet Suburban 1500 problem?

2 Known 1997 Chevrolet Suburban 1500 Brakes Problems

The anti-lock brake system (ABS) front wheel speed sensors are prone to failure. When a sensor fails, the ABS warning light may illuminate and/or the ABS system may activate erratically.
Power brake systems using "hydro-boost" may leak power steering fluid from the hydro-boost unit located behind the brake master cylinder. Replacement of the hydro-boost unit is the common repair to...

3 Known 1997 Chevrolet Suburban 1500 Drive Train Problems

The front or rear differential may develop an abnormal noise due to worn bearings or another internal fault. Our technicians tell us that a complete overhaul of the affected differential is com...
The transmission may develop a harsh 1-2 shift and/or illumination of the Check Engine Light with code P1870 stored. This can be caused by wear of the bore for the TCC isolator and regulator valves...
Our technicians highly recommend that the transmission is serviced every 30,000 miles to avoid problems and maintain optimal operating order.

3 Known 1997 Chevrolet Suburban 1500 Electrical & Lights Problems

A clicking noise may be noted from the turn signal flasher after the turn signals are switched off. This is commonly cause by a faulty turn signal switch which will require replacement.
The windshield wipers may not work intermittently due to a faulty wiper motor control board. Our technicians tell us that lightly taping on the wiper motor when the fault occurs should temporarily ...
The headlight switch used on the Chevrolet Suburban 1500 is known to fail through normal operation. Since the headlight switch is also integrated into the interior lights, a malfunctioning switch c...

8 Known 1997 Chevrolet Suburban 1500 Engine Problems

The intake manifold gasket may develop an external engine oil or coolant leak. In some cases, an internal coolant leak may occur causing coolant to mix with the engine oil. Running the engine with...
The fuel pump may fail causing the engine to stall and not restart. Our technicians recommend replacing the fuel filter every 30,000 miles to help prevent undue strain on the fuel pump.
The spark plugs should be replaced every 100,000 miles. Our technicians recommend replacing the spark plug wires also at this time.

1 Known 1997 Chevrolet Suburban 1500 Exhaust & Emissions Problem

Illumination of the Check Engine Light can be caused by a loose or worn gas cap.

4 Known 1997 Chevrolet Suburban 1500 Heating & Air Conditioning Problems

One or more heater & AC (HVAC) air delivery and/or temperature mode door actuator may fail. This can result in incorrect air delivery or temperature. If this occurs, fault code(s) stored...
Extended life coolant may become contaminated and require cooling system service before the recommended 100,000 miles.
The air conditioning compressor may develop an abnormal noise and require replacement. We recommend that whenever an AC compressor is being replaced for a noise condition, a filter kit should be ...

1 Known 1997 Chevrolet Suburban 1500 Maintenance Problem

Our technicians recommend flushing the brake fluid every 60,000 miles. Brake fluid that is dirty may cause problems in the brake system.

2 Known 1997 Chevrolet Suburban 1500 Miscellaneous Problems

The power door lock actuators may become slow to operate or stop working completely and require replacement.
The inside and outside door handles are prone to breaking.

0 Known 1997 Chevrolet Suburban 1500 Suspension & Steering Problems

24
Known 1997 Chevrolet Suburban 1500 Problems & Complaints

One or more heater & AC (HVAC) air delivery and/or temperature mode door actuator may fail. This can result in incorrect air delivery or temperature. If this occurs, fault code(s) stored...
The front or rear differential may develop an abnormal noise due to worn bearings or another internal fault. Our technicians tell us that a complete overhaul of the affected differential is com...
The power door lock actuators may become slow to operate or stop working completely and require replacement.
Illumination of the Check Engine Light can be caused by a loose or worn gas cap.
The anti-lock brake system (ABS) front wheel speed sensors are prone to failure. When a sensor fails, the ABS warning light may illuminate and/or the ABS system may activate erratically.
A clicking noise may be noted from the turn signal flasher after the turn signals are switched off. This is commonly cause by a faulty turn signal switch which will require replacement.
One or more fuel injectors may become stuck closed causing an engine misfire  and the Check Engine Light to illuminate. Our technicians tell us that this problem can be caused by some fuel additiv...
The inside and outside door handles are prone to breaking.
The quick-connect fittings for the heater hoses tend to leak engine coolant. This problem commonly occurs because the metal housing has become brittle, which can break and cause leaks.
The air conditioning compressor may develop an abnormal noise and require replacement. We recommend that whenever an AC compressor is being replaced for a noise condition, a filter kit should be ...
Power brake systems using "hydro-boost" may leak power steering fluid from the hydro-boost unit located behind the brake master cylinder. Replacement of the hydro-boost unit is the common repair to...
The windshield wipers may not work intermittently due to a faulty wiper motor control board. Our technicians tell us that lightly taping on the wiper motor when the fault occurs should temporarily ...
The fuel pump may fail causing the engine to stall and not restart.
The alternator may fail causing the battery to go dead, or an abnormal noise may develop. The dash warning light may or may not illuminate. A failed alternator will require replacement.
The transmission may develop a harsh 1-2 shift and/or illumination of the Check Engine Light with code P1870 stored. This can be caused by wear of the bore for the TCC isolator and regulator valves...
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Researching a 1997 Chevrolet Suburban 1500?
Get maintenance costs, reviews, recalls and more.