Close

2004 Chevrolet Silverado 1500 HD Problems

Find the most common issues based on 2004 Chevrolet Silverado 1500 HD owner complaints.
Tap theto learn more about the most common 2004 Chevrolet Silverado 1500 HD problems.

Most Common 2004 Chevrolet Silverado 1500 HD Problems

The 4WD transfer case encoder motor position sensor or the selector switch may fail causing the service 4WD message to be displayed. Fault code(s) stored in the transfer case control module will ...
The steering may develop a clunk type noise from the upper intermediate steering shaft. Our technicians tell us that you should check with you local GM dealer to find out what the latest repair is...
The daytime running lights are prone to burning out. Our technicians tell us that the light sockets may show signs of heat damage but usually are OK. Always be sure to use the correct replaceme...
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Looking for a particular 2004 Chevrolet Silverado 1500 HD problem?

3 Known 2004 Chevrolet Silverado 1500 HD Brakes Problems

A poor electrical ground under the battery tray may cause the ABS warning light to illuminate. Our technicians tell us that cleaning and properly securing this ground and also the main ABS ground ...
Units with 4 wheel disk brakes may develop at situation where the park brake does not hold as it should. Our technicians tell us this can be caused by worn park brake shoes located inside the dru...
The anti-lock brake system (ABS) pump may stay running after the ignition is turned off causing the battery to go dead. Our technicians tell us that the ABS control module should be replaced to cor...

2 Known 2004 Chevrolet Silverado 1500 HD Drive Train Problems

The 4WD transfer case encoder motor position sensor or the selector switch may fail causing the service 4WD message to be displayed. Fault code(s) stored in the transfer case control module will ...
Our technicians highly recommend that the transmission is serviced every 30,000 miles to avoid problems and maintain optimal operating order.

5 Known 2004 Chevrolet Silverado 1500 HD Electrical & Lights Problems

The daytime running lights are prone to burning out. Our technicians tell us that the light sockets may show signs of heat damage but usually are OK. Always be sure to use the correct replaceme...
The speedometer or other instrument panel gauge may begin to work erratically at times. Our technicians tell us that the instrument cluster must be sent to a repair facility to correct this fault. ...
A clicking noise may be noted from the turn signal flasher after the turn signals are switched off. This is commonly cause by a faulty turn signal switch which will require replacement.

3 Known 2004 Chevrolet Silverado 1500 HD Engine Problems

A dirty throttle body may cause a lower than normal idle and possible stalling condition. Performing a throttle body service will commonly correct this concern.
The spark plugs should be replaced every 100,000 miles. Our technicians recommend replacing the spark plug wires also at this time.
Fuel pump failures are common on higher mileage models, Resulting in a crank no start condition.

4 Known 2004 Chevrolet Silverado 1500 HD Exhaust & Emissions Problems

Illumination of the Check Engine Light can be caused by a loose or worn gas cap.
The muffler heat shield may become loose on the muffler causing a rattle or popping noise. Our technicians tell us there is a kit available from GM to correct this problem.
One or both secondary air injection check valves may become restricted causing poor air flow resulting in illumination of the Check Engine Light. It is often recommend to replace both check valves...

2 Known 2004 Chevrolet Silverado 1500 HD Heating & Air Conditioning Problems

Extended life coolant may become contaminated and require cooling system service before the recommended 100,000 miles.
One or more heater & AC (HVAC) air delivery and/or temperature mode door actuator may fail. This can result in incorrect air delivery or temperature. If this occurs, fault code(s) stored...

1 Known 2004 Chevrolet Silverado 1500 HD Maintenance Problem

Our technicians recommend flushing the brake fluid every 60,000 miles. Brake fluid that is dirty may cause problems in the brake system.

0 Known 2004 Chevrolet Silverado 1500 HD Miscellaneous Problems

2 Known 2004 Chevrolet Silverado 1500 HD Suspension & Steering Problems

The steering may develop a clunk type noise from the upper intermediate steering shaft. Our technicians tell us that you should check with you local GM dealer to find out what the latest repair is...
The steering wheel position sensor may fail, resulting in the service stability message being displayed.

22
Known 2004 Chevrolet Silverado 1500 HD Problems & Complaints

The 2004-2009 Silverado 1500HD has known issues with the EVAP system, a part of your emission control system. The EVAP canister vent valve or valve solenoid wiring may fail causing illumination of...
The 4WD transfer case encoder motor position sensor or the selector switch may fail causing the service 4WD message to be displayed. Fault code(s) stored in the transfer case control module will ...
The anti-lock brake system (ABS) pump may stay running after the ignition is turned off causing the battery to go dead. Our technicians tell us that the ABS control module should be replaced to cor...
The muffler heat shield may become loose on the muffler causing a rattle or popping noise. Our technicians tell us there is a kit available from GM to correct this problem.
The daytime running lights are prone to burning out. Our technicians tell us that the light sockets may show signs of heat damage but usually are OK. Always be sure to use the correct replaceme...
A poor electrical ground under the battery tray may cause the ABS warning light to illuminate. Our technicians tell us that cleaning and properly securing this ground and also the main ABS ground ...
Units with 4 wheel disk brakes may develop at situation where the park brake does not hold as it should. Our technicians tell us this can be caused by worn park brake shoes located inside the dru...
A clicking noise may be noted from the turn signal flasher after the turn signals are switched off. This is commonly cause by a faulty turn signal switch which will require replacement.
The speedometer or other instrument panel gauge may begin to work erratically at times. Our technicians tell us that the instrument cluster must be sent to a repair facility to correct this fault. ...
The steering may develop a clunk type noise from the upper intermediate steering shaft. Our technicians tell us that you should check with you local GM dealer to find out what the latest repair is...
Fuel pump failures are common on higher mileage models, Resulting in a crank no start condition.
The headlight switch used on the Chevrolet Silverado 1500HD and 2500HD is known to fail through normal operation. Since the headlight switch is also integrated into the interior lights, a malfuncti...
A dirty throttle body may cause a lower than normal idle and possible stalling condition. Performing a throttle body service will commonly correct this concern.
It is common for the fuel level sensor in the fuel tank read the fuel level incorrectly. The sensor must be replaced to correct the condition. Our technicians recommend having the complete fuel pum...
The spark plugs should be replaced every 100,000 miles. Our technicians recommend replacing the spark plug wires also at this time.
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Researching a 2004 Chevrolet Silverado 1500 HD?
Get maintenance costs, reviews, recalls and more.