1991 Ford Thunderbird SC Repair and Maintenance

A guide to problems, costs, maintenance and repair for your 1991 Ford Thunderbird SC

No_car_image
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
Get a Repair Estimate For Your 1991 Ford Thunderbird SC
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more

1991 Ford Thunderbird SC Problems

Coolant Loss, Engine Overheating, White Smoke From Exhaust

White smoke coming from the exhaust could indicate that a head gasket has blown or there is a cracked cylinder head. Our technicians tell us that removal and inspection of the cylinder heads will be required to confirm a crack is present.

Updated electrical ignition switch available to address fire hazard

For the 2.3L 4 Cylinder and 5.0L V8 engine, the electrical ignition switch poses a fire hazard. An updated switch is available.

Clunk and/or Rattle Due to Worn Inner Tire Rod Ends

While steering, if you hear a clunk or a rattle, or if you experience premature tire wear, this could indicate the inner tie rod ends are loose or worn and will require replacement.

See More Problems (5)

1991 Ford Thunderbird SC Questions

Pushrod... What type of lube should I use in the supercharger on my 91third sc? (1 answer)

where is the hydraulic pump relay located on my t bird (1 answer)

I have tested for power to pump. when i put power to pump it runs fine i dont know where the relay is

When the key is turned to start nothing happens. Jump to starter works, no fire (4 answers)

All of the underhood checks happen when the key is in the on position,fuel pump charges, but when the key is turned to start nothing happens. Every thing worked until I had the engine rebuilt. Everything is plugged back in and the grounds are in place. Jumper wire from the starter solenoid to t...

See More Questions (7)

1991 Ford Thunderbird SC Reviews

Rated
based on 2 customer reviews
Got it for 1000 with a bad transmission. Got a used AOD for 250.Hhead gaskets went but fix myself. still running strong.Sleeper
Given a 1991 Ford Thunderbird Super Coupe from a family member. The car ran great the past couple years with very minor issues but recently the Brake Master Cylinder with ABS went out and reportibly is a pretty expensive part and hard to find. Very fun car to drive and spin but I'm heart broken that I might need to junk it if I can't find a replacement part or rebuilt it for less than a for...

See More Reviews (2)