1994 Chevrolet Suburban 2500 Repair and Maintenance

A guide to problems, costs, maintenance and repair for your 1994 Chevrolet Suburban 2500

No_car
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
Get a Repair Estimate For Your 1994 Chevrolet Suburban 2500
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Repair Estimates
Caret_down

Never overpay. Check prices with our estimator

1994 Chevrolet Suburban 2500
$
123
to $
785
1994 Chevrolet Suburban 2500
$
297
to $
1,429
1994 Chevrolet Suburban 2500
$
101
to $
643
1994 Chevrolet Suburban 2500
$
326
to $
920
1994 Chevrolet Suburban 2500
$
442
to $
1,081

1994 Chevrolet Suburban 2500 Problems

Power Brake Units May Leak Fluid From Hydro-Boost Unit

Power brake systems using "hydro-boost" may leak power steering fluid from the hydro-boost unit located behind the brake master cylinder. Replacement of the hydro-boost unit is the common repair to correct this concern.

Replace Fuel Filter Every 30,000 to Prevent Fuel Pump Failure

The fuel pump may fail causing the engine to stall and not restart. Our technicians recommend replacing the fuel filter every 30,000 miles to help prevent undue strain on the fuel pump.

Heating and AC Temperature and Air Delivery Mode Door Actuators May Fail

One or more heater & AC (HVAC) air delivery and/or temperature mode door actuator may fail. This can result in incorrect air delivery or temperature. If this occurs, fault code(s) stored in the HVAC control module should be available to assist with diagnoses.

See More Problems (16)

1994 Chevrolet Suburban 2500 Questions

Can't get power steering and brakes to work. Replaced pump, hoses and pulleys. Power brakes don't work and power steering failed. All new parts except where hoses attach to booster, but that was working before. Don't know what the problem is. Can U help? (1 answer)

Belt seemed to be squealing so I replaced the water pump, and kept making noise. Replaced AC condenser and filled with coolant, made noise still replaced power steering pump and hoses for brakes too. Now don't have power brakes or power steering and trans is slipping too. I need some guidance...

need info about insrument cluster and wiring on 94 chevy suburban, no lights (1 answer)

am mech have own shop been at this for days

i changed my trans fluid and filter about a month ago. (1 answer)

the truck ran fine for about a week, then started stuttering on take off from a stop. after that it started shaking and stuttering worse when id turn left. thot it was points, so i got a new cap and roter. ran great again for a couple of days then started doing it again. my wife when to yakima to...

See More Questions (9)

1994 Chevrolet Suburban 2500 Recalls

Recall 03V159000
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Recall 01I006000
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1992-1994 CHEVROLET AND GMC SUBURBANS EQUIPPED WITH VACUUM POWER-BRAKE ASSIST AND EBC4 ANTI-LOCK BRAKE (ABS) MODULES. THESE VEHICLES EXHIBIT ...
Recall 99V025000
VEHICLE DESCRIPTION: PICKUP TRUCKS, CREW CABS, UTILITY TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES WERE BUILT WITH THE POLARITY OF THE WIRING FOR THE ZERO ADJUST BRAKE SWITCH REVERSED FROM WHAT WAS SPECIFIED ON THE SWITCH DRAWING. WITH THE REVERSED POLARITY, THE CONTACTS IN THE BRAKE SWI...

See More Recalls (5)