» »

Car Recalls

Recalls are issued for cars with safety-related defects or problems

Volvo XC90 recalls

 

For Models: Volvo XC90

Suspension & Steering, May 12, 2011

RepairPal Expert Overview:

Power steering fluid may leak from the pipe connection at the steering gear valve housing. This could lead to a sudden loss of power steering, increasing the risk of a crash. Dealers will replace the oil pipes on the power steering rack to correct this concern. This recall is expected to begin on May 31, 2011. The Volvo recall number is R242.

For Models: Volvo C30, Volvo C70, Volvo S40, Volvo S60, Volvo S80, Volvo V50, Volvo V70, Volvo XC70, Volvo XC90

Electrical & Lights, November 5, 2010

RepairPal Expert Overview:

Volvo is recalling all models equipped with Garmin 760 Portable Global Positioning System units because the battery may overheat, which could lead to a fire. Volvo advises owners to stop using the Garmin device immediately and consult the Garmin website to determine if they have a defective unit. The unit's battery will be replaced and a spacer inserted to prevent the problem from reoccurring. This will be performed free of charge.

For Models: Volvo XC90

Body, Interior & Misc., April 23, 2010

RepairPal Expert Overview:

The fuel line may leak at a connector near the right front wheel area. A fuel leak near an ignition source is a fire hazard. Dealers will inspect the fuel line date code and replace the line if it falls in the affected date range. The Volvo recall number is R224. This recall began on April 23, 2010.

For Models: Volvo S60, Volvo S80, Volvo V70, Volvo XC70, Volvo XC90

Engine, January 15, 2010

RepairPal Expert Overview:

When exposed to certain environmental conditions (hot climate and temperature cycling) over time and in combination with varying fuel quality, the fuel pump can develop cracks in the fuel pump flange. If cracks develop, a fuel smell and/or leak may be noted. Any fuel leak always increases the risk of a fire. Dealers will inspect and replace the fuel pump as necessary to correct this concern. The Volvo recall number is R220.

For Models: Volvo S80, Volvo XC90

Engine, May 2, 2008

RepairPal Expert Overview:

One hundred and two vehicles may have been assembled with incorrect bolts securing the engine mount. The aluminum engine mount bracket could break, resulting in excess engine movement. This could lead to an engine stalling condition, increasing the risk of a crash. Owners of the affected vehicles have been contacted and dealers will perform the necessary repairs. The Volvo recall number is 197.

For Models: Volvo XC90

Body, Interior & Misc., January 28, 2008

RepairPal Expert Overview:

The climate control system may not work from the time of startup due a software issue. If the defroster does not function, a loss of visibility may occur for the driver, causing a safety issue. Dealers will reprogram the software for the climate control module. The Volvo recall number is 185. This recall began on January 8, 2011

For Models: Volvo XC90

Electrical & Lights, July 3, 2007

RepairPal Expert Overview:

While performing battery maintenance, the crank handle for the jack can be misplaced under the battery retaining bracket, which could short circuit the battery, increasing the risk of a fire. Dealers will inspect and ensure proper placement of the jack handle and install a warning label to the battery retaining bracket. This recall is expected to begin on July 2, 2007. The Volvo recall number is SC179.

For Models: Volvo XC90

Body, Interior & Misc., September 5, 2006

RepairPal Expert Overview:

If the windshield wipers are activated in extreme winter weather conditions and without lifting the wiper arms and cleaning the windshield prior to moving, the wiper arm can slip on its driveshaft, resulting in an inability to move the wipers from the park position. Inoperative wipers during inclement weather conditions could cause a crash due to reduced visibility. Dealers will replace the wiper arms and retaining nuts to correct this concern. The Volvo recall number is R156.

 

For Models: Volvo XC90

Suspension & Steering, June 23, 2006

RepairPal Expert Overview:

The outer tie rod ball joint may fatigue and fracture. The driver may notice the vehicle is difficult to maneuver, increasing the risk of a crash. Dealers will replace the outer tie rod ends to correct this concern. The Volvo recall number is R157.

For Models: Volvo S80, Volvo XC90

Electrical & Lights, January 31, 2006

RepairPal Expert Overview:

An electrical short circuit may develop between the positive battery and ground at the starter motor solenoid. Smoke may appear from under the hood and the car may not start. If the short were to occur while driving, electrical power could be lost. Any electrical short increases the risk of a fire. Dealers will inspect and increase the distance between the B+ terminal and the starter motor solenoid as necessary. This recall is expected to begin on January 31, 2006. The Volvo recall number is R150.

Ask a Question
More about this car