The left door handle cable may not be attached properly. This may cause a safety issue during a collision. Dealers will adjust the door handle cable and secure it. The Volvo recall number is R180. The recall began on June 29, 2007.
The fuel pressure sensor may at times transmit an incorrect signal to the engine control module. If the signal is outside of the pre-programmed allowable limits, the Check Engine Light can illuminate and a fault code will be stored. An engine misfire and/or engine stalling may occur. In certain traffic situations, this could cause an unsafe situation and possibly a crash. Dealers will replace the fuel pressure sensor to correct this concern. The Volvo recall number is R181.
The tire pressure and loading information label may be incorrect. This could lead to improper vehicle loading or tire pressures that could result in a tire failure. Dealers will mail the correct label to vehicle owners. This recall is expected to begin on December 18, 2006. The Volvo recall number is 161.
If the windshield wipers are activated in extreme winter weather conditions and without lifting the wiper arms and cleaning the windshield prior to moving, the wiper arm can slip on its driveshaft, resulting in an inability to move the wipers from the park position. Inoperative wipers during inclement weather conditions could cause a crash due to reduced visibility. Dealers will replace the wiper arms and retaining nuts to correct this concern. The Volvo recall number is R156.
The outer tie rod ball joint may fatigue and fracture. The driver may notice the vehicle is difficult to maneuver, increasing the risk of a crash. Dealers will replace the outer tie rod ends to correct this concern. The Volvo recall number is R157.
An electrical short circuit may develop between the positive battery and ground at the starter motor solenoid. Smoke may appear from under the hood and the car may not start. If the short were to occur while driving, electrical power could be lost. Any electrical short increases the risk of a fire. Dealers will inspect and increase the distance between the B+ terminal and the starter motor solenoid as necessary. This recall is expected to begin on January 31, 2006. The Volvo recall number is R150.