2002 Volvo S80 Problem Reports

Newest 2002 Volvo S80 Problem Reports

Report A Problem

Many complaints have been reported regarding Volvo S80 transmission shifting issues. Long shift times between gear shifts, hard shifting, hard downshifting and a loss of transmission operation all together to name a few.

If the issue is minor, a transmission software update may address this issue so if available, the software should be updated before any repairs are made. After a software update or repair, the shift adaptation needs to be reset. A good quality Volvo repair shop will know how to perform this task.

There are several technical service bulletins (TSB's) available from Volvo that address these shifting issues and they should be consulted by the repair shop during the automatic transmission diagnostic process.

Regular servicing of the transmission fluid can help with preventing transmission failure, but not in all cases. Follow the suggested fluid replacement interval recommended by Volvo. You will find this in your owners manual, or find it here: http://bit.ly/Volvo_Owners_Manuals

at 103K the Car began a high pitched hum or squeal after the car warmed up. The squealing could be temporarily stopped by pressing the accelerator. The car was diagnosed as a cracked breather box, also known as, the flame trap, the oil trap. A small plastic box connected to the PCV System that has a plastic nipple that cracks and squeals form the oil pressure. The repair is difficult to get to and costs a lot in labor. My technician told me t...

The anti-lock brake system (ABS) warning light and/or other dash warning lights may illuminate due to a failed ABS Control Module. Replacement of the failed module is generally required to correct this concern.

The mass air flow (MAF) sensor may fail, resulting in drivability issues and/or illumination of the Check Engine Light.

During the diagnosis of the symptoms the technician may pull diagnostic codes from the Engine Control Module that point to a lean air/fuel mixture. If no vacuum leaks are found, then the mass air flow sensor (MAF) is often the cause.

Replacement of the MAF will be needed, along with a reset of the Engine Control Module and erasing of the diagnostic trouble codes.

The front control arm bushings wear out, resulting in alignment issues and squeaking and/or knocking noises from the front end. Worn bushings will require replacement.

 

Engine oil leaks from the PCV housing and turbocharger oil return line seals have been reported.

Front upper strut mounts may wear prematurely, resulting in loud noise from the front of the vehicle when going over bumps.

Front and/or rear sway bar end links may wear out prematurely, causing a knocking noise from the front or rear of the vehicle when driving on bumpy roads. Our technicians recommend inspecting the links at each service, they should be replaced if any looseness is found.

Transmission issues related to shifting have been reported. Software upgrades available from Volvo often resolve these problems.