Problem with your car? See what our experts say or submit your own.
2001 Volvo S60 Problems
Had a strong gasoline odor for about a week after last major service. Found out there was an extended warranty on the fuel pump and although my warranty had expired (soonest of 10 years or 150,000 miles) Volvo covered the replacement although it had to be done at dealer and not garage I normally use. Nearest dealership is 41 miles away from where I live. Dealer was very accomodating after checking with Volvo Customer Service but had to have c...
The automatic transmission may develop shifting problems and/or the Check Engine Light may illuminate due to internal component failure and/or software issues. It is always best to be sure the transmission control module has the latest software installed when any major transmission repair is performed.
The front control arm bushings wear out, resulting in alignment issues and squeaking and/or knocking noises from the front end. Worn bushings will require replacement.
The Electronic Throttle Module (ETM) has a higher than normal failure rate. Volvo has extended the warranty on some of the ETMs to 10 years/200,000 miles
It is not uncommon for the exterior light bulbs to burn out prematurely. No repair option has been reported other than replacing the failed bulb.
One or both of the front wheel bearings may fail resulting in a rumbling noise from the front wheel area when driving over 25 mph.
Several complaints have been reported regarding Volvo S60 transmission shifting issues. Long shift times between gear shifts, hard shifting, hard downshifting and a loss of transmission operation all together to name a few.
If the issue is minor, a transmission software update may fix this issue. If available, the software should be updated before any repairs are made.
There are several technical service bulletins (TSB's) available from Volvo that address these shifting issues and they should be consulted by the repair shop during the automatic transmission diagnostic process.
Regular servicing of the transmission fluid can help with preventing transmission failure, but not in all cases. Follow the suggested fluid replacement interval recommended by Volvo. You will find this in your owners manual, or find it here: http://bit.ly/Volvo_Owners_Manuals
There is a computer that controls all these items and it's called the rear electrical module, or the "REM". To temporarily address this issue you can pull the fuse from the rear fuse box labeled "REM" and everything should start working again.
Volvo has updated software for the REM that will help prevent this from happening again. See a Volvo shop or Dealer and have this and all the software in the vehicle checked and updated every 30,000 miles.
Front upper strut mounts may wear prematurely, resulting in loud noise from the front of the vehicle when going over bumps.
Front and/or rear sway bar end links may wear out prematurely, causing a knocking noise from the front or rear of the vehicle when driving on bumpy roads. Our technicians recommend inspecting the links at each service, they should be replaced if any looseness is found.