1996 Volvo 960 Problem Reports

Newest 1996 Volvo 960 Problem Reports

Report A Problem

I have severe engine shaking on start up. Today is quite hot In Florida
I do NOT have a check engine light on. Help. Thx

The front control arm bushings wear out, resulting in alignment issues and squeaking and/or knocking noises from the front end. Worn bushings will require replacement.

The gear position sensor on the transmission may fail, resulting in illumination of the Check Engine Light and/or a no start condition.

A refrigerant leak may develop from the AC evaporator causing the AC to blow warm air. Verifying failure of this component is difficult. A good shop will use leak detection dye to verify a failing evaporator.

The sway bar bushings commonly wear out, causing a knocking noise from the front of the vehicle. Replacing the worn bushings should correct this concern.

Oil in coolant. Had to replace head gaskets.

Vibration problems from the rear brake rotors are common and require replacement of the pads and rotors, and the installation of special shims. The symptoms often occur when the brakes are used heavily from repeated braking, braking from high speeds, and braking while going downhill. The entire vehicle can vibrate and shudder, like it is being driven over train tracks.

The intake manifold gasket will often be a source of vacuum leaks. This will cause a rough idle and the Check Engine Light will illuminate. Replacement of the gasket is required to resolve this issue.