2008 Saturn Aura Problems

RepairPal has identified the most common problems with the 2008 Saturn Aura as reported by actual vehicle owners. We'll tell you what the problem is and what it'll take to fix it.

Refine by vehicle
×
Choose your vehicle
9
Known Problems

A Loose or worn gas cap may cause Check Engine Light to illuminate.

Non-Hybrid Saturn Aura models may display the warning message "A/C off for Engine Protection" on the instrument panel. This may be accompanied by illumination of the check engine light and the temperature gauge reading cold at all times. This is a feature of the engine that is activated by the power control module when it detects the engine warming up too slowly. The OBD trouble code P0128 may also be stored. 

The cause is simply a worn out thermostat that stays open at all times, preventing the engine from reaching the proper operating temperature. 

Replacement of the thermostat will correct the issue. 

Vehicles with certain V6 engines may illuminate the Check Engine Light one or more of the following codes: P0011, P0014, P0021, P0024, P0341, P0346, P0336, or P0391. Our technicians tell us that some vehicles may require a powertrain control module (PCM) software update to correct this issue. Other vehicles may have excess camshaft end play on one or both cylinder heads which will need to be corrected using special procedures outlined by GM.

Vehicles with a 6speed automatic transmission may develop one or more of the following faults related to a broken 35R clutch wave plate inside the transmission: Illumination of the Check Engine Light with code P0716, P0776, P0717, P0777, P2714, P2715, and/or P02723, loss of reverse gear, slipping or harsh 3rd or 5th gear shift. Removal and dis-assembly of the transmission will be required to replace the broken 35R wave plate. It is also extremely important that all debris from the failed part be cleaned from the transmission while it is disassembled in order to try and prevent future problems.

The fuel gauge may not read correctly and/or the Check Engine Light may illuminate with code P0455/P0461 stored for a fuel level sensor issue. These faults may be caused by a fuel vapor line inside the fuel take interfering with the fuel level sensor. If this is found to be the case, repositioned and securing the vapor line should correct this concern. If no fault is found with the fuel vapor line, the fuel level sensor itself may be at fault.

 

 

Extended life coolant may become contaminated and require cooling system service before the recommended 100,000 miles.

Brake fluid can become dirty and may cause problems in the brake system; it should be flushed every 60,000 miles.

3.5L V6
The spark plugs should be replaced every 100,000 miles. Our technicians recommend replacing the spark plug wires also at this time.

The 30amp high speed cooling fan fuse may blow due to high start up loads associated with the high speed cooling fan motor. Our technicians tell us the high speed cooling fan wiring and fuse should be upgraded to a 40amp circuit to correct this concern. The fan wiring MUST be upgraded along with the fuse to handle the increased current flow.