The Fuel Pump May Fail Causing the Engine to Stall or Crank Over But Not Start on Chevrolet Suburban 1500

The fuel pump may fail causing the engine to stall and not restart. Our technicians recommend replacing the fuel filter every 30,000 miles to help prevent undue strain on the fuel pump.

RepairPal Verified
Average mileage: 141,646 (11,200–240,000)
Engines affected: 5.7L V8, 6.5L V8 Diesel Turbo, Gasoline
14 model years affected: 1992, 1993, 1994, 1995, more1996, 1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2011
45 people reported this problem
20 people shared problem details
1999 Chevrolet Suburban 1500- 5.7L V8185,946
1998 Chevrolet Suburban 1500- 5.7L V8186,000
engine wil crank but it sputters and cuts out
same as everyone else. Fuel pump went out. Truck started acting weird... lights flashing on and off in the interior; door locking and unlocking; alarm not setting... not sure how that is related to fuel pump. But, had it towed to dealership and they replaced the fuel pump. That fixed the problem.
My truck would not take the gas while driving down the street then cut off. After sitting for 15 minutes or so it would crank back up and drive a little while longer then repeat it all over again. I had to replace the fuel pump.
1995 Chevrolet Suburban 1500- 5.7L V8180,000
Chugs while decelerating and accelerating at any given time of day. about to replace third fuel pump in as many years. will change fuel filter also.
engine hard to start, already replace the throttle body assy,,but still hard to start only when i press the gas pedal but when release engine die
Failed to start or hard to keep running at idle required replacement of fuel pump
1996 Chevrolet Suburban 1500- 6.5L V8 Diesel Turbo11,200
fuell pump problems
fuel pump replaced after 210012 miles.
1999 Chevrolet Suburban 1500- 5.7L V8198,000
The fuel pump just dies with no warning, it started in the morning but would not start later in the day.
I purchased this used in May 2015 and have had to replace the fuel pump module sensor in July 15 and again last week. It wouldn't start again this morning having just had one replaced last week and it is now being towed to dealership. Upon further research the fuel pump module sensor has been replaced 4 times since April 2014. Chevy corporate said they would contact e dealership to research but hey said that last week and I was still sent on my way. If he vehicle cuts out when I am driving, to my understanding, I will lose power steering and power brakes. What do I do?
I replaced the fuel pump and the motor just turns over but wont start the motor just died while I was driving it just keeped turning over sounded like fuel pump went out so i replaced it but it still just turns over and still won't start
1999 Chevrolet Suburban 1500- 5.7L V8168,000
Truck stopped turning over. Stalled on several occasions. Thought it was the starter. Turned out to be fuel
Replace fuel pump still won't crank
Fuel Pump needed to be replaced.
1997 Chevrolet Suburban 1500- 5.7L V8225,000
Engine stalled and didn't restart.
Under a 1/4 tank of gas its hard to start
Fuel pump failed right after filling up with gas. Ran rough, then backfired and wouldnt start. Found a replacement, mechanic, and replaced the pump in the parking lot.
fuel pump continued to lose prime so DROPPED THE TANK, and replaced the fuel pump, filter, and had the fuel injectors cleaned and the regulator replaced while there.
1997 Chevrolet Suburban 1500- 5.7L V8100,000
fuel pump went out
Related Items:
1992 chev suburban half ton 2wd with rear tank. Truck would stall during driving and wouldn't s...
is there an access panel to change the fuel pump or do i drop the tank
car has all power and fuel pump runs but no start? replaced crankshaft position sensor because...
replaced fuel filter, now it will not start. Is there a reset switch to the fuel system.

Related Content