Plymouth Grand Voyager Problem Reports
Report A Problem
Some of the "idiot" and other indicator lights were intermittently failing just after I bought our van used a year ago. Most repair info suggested replacing the instrument cluster, but upon further digging I found the true problem is cold (bad) solder joints in the circuit board at the FACTORY!
Having 9 years professional electronics repair experience, all I had to do was yank the cluster, reflow EVERY soldered connection on the board, d...
A defective anti-lock brake system (ABS) pump and/or leaking piston seals in the master cylinder can cause excessive pedal effort, lack of stopping power, and abnormal pump noise. Diagnoses will be required to determine the root cause of any braking issues and the component(s) that will require replacement.
The speedometer may become inoperative due to a failed vehicle speed sensor (VSS), . A failed sensor will require replacement.
The door ajar light may illuminate and chime during driving, even when the sliding door is closed. Often, this is caused by a faulty switch in the C-pillar; a revised switch is available.
A delay in the transaxle engagement (greater than three seconds) may have multiple causes, including a defective pump, defective internal lip seals, valve body components, park-reverse-neutral-drive lever switch, and the output speed sensor. Proper diagnoses will be necessary to determine the exact cause.
Voltage spikes can cause erratic behavior in the electrical system (lights, locks, wipers, head lamps). This is often caused by relays. Inspection and replacement of relays is required; revised relays are available.
Illuminated of the airbag warning light may be caused by a lost connection between the clockspring (behind the steering wheel) and the steering wheel-mounted electrical components. Other steering wheel-mounted controls like the horn, speed (cruise) control, or radio controls (if equipped) may be inoperative. There is a lifetime warranty on the clockspring as specified in a combination of recall campaigns. For more information on these recalls please us the following links; 1996-1998 models, please click here». For 1998-2000 models, please click here»
The airbag warning light may remain illuminated while the ignition switch is in the "on" position. This can be caused by water that has entered into the airbag six-way connector in the engine compartment.
Sometimes the vent windows' latch can pop open; if it will not stay closed or rattles, the latch assembly should be replaced.
AWD equipped vehicles can show a wide range of transmission problems, often caused by using the wrong-sized and/or mismatched tires. Be sure that all the tires are the same and that all four are replaced at the same time. Dodge recommends tire rotation every 7,500 miles.
A momentary loss of power steering can occur when the AC or defroster is on during high humidity conditions. This is due to condensation from the evaporator draining onto the serpentine belt. To fix the problem, a spout on the AC evaporator drain and a new serpentine belt should be installed. Some vehicles may need a revised serpentine belt tensioner.
A problem with the sliding door track and door stops can allow the door to slide out of the track and fall off the vehicle. This is more common when doors are opened fast and allowed to hit the stops with a lot of force.