» »

Problems for specific Chevrolet G Series Van (G20) years:

Car problem reports

Report A Problem

Problem with your car? See what our experts say or submit your own.

Repairpal verified Chevrolet G Series Van (G20) problems

 

Verified for the Chevrolet G Series Van (G20)

One or more fuel injectors may become stuck closed causing an engine misfire  and the Check Engine Light to illuminate. Our technicians tell us that this problem can be caused by some fuel additives. There are special procedures which may be able to restore the affected injector. If this fails the affected injector must be replaced.

3 Reports
Me Too

Verified for the Chevrolet G Series Van (G20)

The distributor may develop internal faults. This can cause a rough running engine or stalling condition, the Check Engine Light may or may not illuminate. Our technicians tell us that the distributor should be overhauled or replaced to correct this concern.

6 Reports
Me Too

Verified for the Chevrolet G Series Van (G20)

The engine may develop a misfire due to worn valve seats. This fault will cause the Check Engine Light to illuminate. Our technicians tell us the misfire may or may not be felt while driving. They further recommend that both cylinder heads be removed and thoroughly inspected and repaired as necessary.

3 Reports
Me Too

Verified for the Chevrolet G Series Van (G20)

The intake manifold gasket may develop and external engine oil or coolant leak. In some cases, an internal coolant leak may occur causing coolant to mix with the engine oil. Running the engine with a coolant/oil mix may result in engine damage. Replacing the intake manifold gasket should correct this issue.

13 Reports
Me Too

Verified for the Chevrolet G Series Van (G20)

A loose or worn gas cap could be cause the Check Engine Light to illuminate.

3 Reports
Me Too

Verified for the Chevrolet G Series Van (G20)

The alternator may fail causing the battery to go dead. The charge light on the dash may or may not illuminate. The alternator may also develop an abnormal noise. A failed alternator will require replacement.

6 Reports
Me Too

Verified for the Chevrolet G Series Van (G20)

The alternator may fail causing the battery to go dead. The charge light on the dash may or may not illuminate. The alternator may also develop an abnormal noise. A failed alternator will require replacement.

4 Reports
Me Too

Verified for the Chevrolet G Series Van (G20)

On the 4L80-E Transmission (Diesel and 7.4L gas engine), Transmission fluid may leak through the electrical connector on the side of the transmission, damaging the wire harness and causing the transmission to shift erratically. Our technicians tell us there are updated shift solenoids, an internal  transmission harness, and a connector pigtail available to correct this fault.

3 Reports
Me Too

Verified for the Chevrolet G Series Van (G20)

An oil leak may develop from the distributor o-ring seal requiring replacement of the seal.

7 Reports
Me Too

Verified for the Chevrolet G Series Van (G20)

An engine vacuum leak may develop from the throttle body gasket causing a higher than normal idle speed. Failed gaskets should be replaced.

8 Reports
Me Too

Verified for the Chevrolet G Series Van (G20)

A coolant leak may develop from the water pump. This can result in an engine overheating condition. A leaking water pump will require replacement.

12 Reports
Me Too

Verified for the Chevrolet G Series Van (G20)

The fuel pump may fail causing the engine to stall and not restart. Our technicians recommend replacing the fuel filter every 30,000 miles to help prevent undue strain on the fuel pump.

9 Reports
Me Too
Ask a Question
More about this car