» » »

Problems for specific Plymouth Voyager years:

Car problem reports

Report A Problem

Problem with your car? See what our experts say or submit your own.

Repairpal verified 1991 Plymouth Voyager problems

 

Verified for the Plymouth Voyager

A defective anti-lock brake system (ABS) pump and/or leaking piston seals in the master cylinder can cause excessive pedal effort, lack of stopping power, and abnormal pump noise. Diagnoses will be required to determine the root cause of any braking issues and the component(s) that will require replacement.

3 Reports
Me Too

Verified for the Plymouth Voyager

The speedometer may become inoperative due to a failed vehicle speed sensor (VSS), . A failed sensor will require replacement.

9 Reports
Me Too

Verified for the Plymouth Voyager

The door ajar light may illuminate and chime during driving, even when the sliding door is closed. Often, this is caused by a faulty switch in the C-pillar; a revised switch is available.

3 Reports
Me Too

Verified for the Plymouth Voyager

Voltage spikes can cause erratic behavior in the electrical system (lights, locks, wipers, head lamps). This is often caused by relays. Inspection and replacement  of relays is required; revised relays are available.

3 Reports
Me Too

Verified for the Plymouth Voyager

The airbag warning light may remain illuminated while the ignition switch is in the "on" position. This can be caused by water that has entered into the airbag six-way connector in the engine compartment.

3 Reports
Me Too

Verified for the Plymouth Voyager

Sometimes the vent windows' latch can pop open; if it will not stay closed or rattles, the latch assembly should be replaced.

8 Reports
Me Too

Verified for the Plymouth Voyager

A problem with the sliding door track and door stops can allow the door to slide out of the track and fall off the vehicle. This is more common when doors are opened fast and allowed to hit the stops with a lot of force.

11 Reports
Me Too

Verified for the Plymouth Voyager

Common areas for engine oil leaks include the camshaft plug, camshaft seal (sprocket end), valve cover gaskets, cylinder head gasket and distributor.

2 Reports
Me Too

Verified for the Plymouth Voyager

A refrigerant leak at the rear AC expansion valve and/or AC evaporator seals may cause the rear AC not to work.

6 Reports
Me Too

Verified for the Plymouth Voyager

Timing cover oil and coolant leaks are common, the oil and coolant don't normally mix. Our technicians recommend to replace the timing chain and cam sprocket if the timing cover is removed to reseal - or for any other reason.

6 Reports
Me Too

Verified for the Plymouth Voyager

The rear lift gate support (prop) attaching bolts may break, causing the lift gate to fall unexpectedly. Thorough inspection of the bolts is required; if the support washers are loose, the supports need to be replaced.

7 Reports
Me Too

Verified for the Plymouth Voyager

Excessive oil consumption—defined as more than one quart per 1,000 miles (on vehicles with less than 50,000 miles) or more than one quart per 750 miles (on vehicles with more than 50,000 miles)—is common. Common causes include exhaust valve guides, valve cover gaskets, camshaft plugs, camshaft seals, and crankshaft seal.

1 Report
Me Too

Verified for the Plymouth Voyager

Triggered by a short in the rear wiper motor/circuit (which causes a fuse to blow), the airbag warning light can illuminate erroneously.

6 Reports
Me Too

Verified for the Plymouth Voyager
The transmission has numerous problems; symptoms can range from shuddering to completely dying. The majority of the TSBs (service bulletins) require an overhaul of the transmission. Updated internal parts are available. 
2 Reports
Me Too

Verified for the Plymouth Voyager
An intermittent loss of speed control can happen soon after the transaxle input or output speed sensor has been replaced. The problem is most likely caused by bad connectors.
8 Reports
Me Too
Ask a Question