A defective anti-lock brake system (ABS) pump and/or leaking piston seals in the master cylinder can cause excessive pedal effort, lack of stopping power, and abnormal pump noise. Diagnoses will be required to determine the root cause of any braking issues and the component(s) that will require replacement.
Problems for specific Plymouth Grand Voyager years:
Car problem reports
Problem with your car? See what our experts say or submit your own.
Newest reported 1992 Plymouth Grand Voyager problems
The speedometer may become inoperative due to a failed vehicle speed sensor (VSS), . A failed sensor will require replacement.
The door ajar light may illuminate and chime during driving, even when the sliding door is closed. Often, this is caused by a faulty switch in the C-pillar; a revised switch is available.
Voltage spikes can cause erratic behavior in the electrical system (lights, locks, wipers, head lamps). This is often caused by relays. Inspection and replacement of relays is required; revised relays are available.
The airbag warning light may remain illuminated while the ignition switch is in the "on" position. This can be caused by water that has entered into the airbag six-way connector in the engine compartment.
Sometimes the vent windows' latch can pop open; if it will not stay closed or rattles, the latch assembly should be replaced.
A problem with the sliding door track and door stops can allow the door to slide out of the track and fall off the vehicle. This is more common when doors are opened fast and allowed to hit the stops with a lot of force.
The rear lift gate support (prop) attaching bolts may break, causing the lift gate to fall unexpectedly. Thorough inspection of the bolts is required; if the support washers are loose, the supports need to be replaced.
A loosening (or loss) of the nut retaining the engine cooling fan can cause a vibration. If not addressed promptly, the fan blade may not turn, causing the engine to overheat. A revised engine cooling fan retaining nut kit has been released.
Carbon buildup on the top of the piston is common. As the buildup increases with mileage and over time, symptoms vary from light ticking, to ticking/hammering, to hammering/knocking noises. Fuel injector cleaner often solves the problem.
Triggered by a short in the rear wiper motor/circuit (which causes a fuse to blow), the airbag warning light can illuminate erroneously.