1991 Plymouth Grand Voyager Problem Reports

Newest 1991 Plymouth Grand Voyager Problem Reports

Report A Problem

A defective anti-lock brake system (ABS) pump and/or leaking piston seals in the master cylinder can cause excessive pedal effort, lack of stopping power, and abnormal pump noise. Diagnoses will be required to determine the root cause of any braking issues and the component(s) that will require replacement.

The speedometer may become inoperative due to a failed vehicle speed sensor (VSS), . A failed sensor will require replacement.

The door ajar light may illuminate and chime during driving, even when the sliding door is closed. Often, this is caused by a faulty switch in the C-pillar; a revised switch is available.

Voltage spikes can cause erratic behavior in the electrical system (lights, locks, wipers, head lamps). This is often caused by relays. Inspection and replacement  of relays is required; revised relays are available.

The airbag warning light may remain illuminated while the ignition switch is in the "on" position. This can be caused by water that has entered into the airbag six-way connector in the engine compartment.

Sometimes the vent windows' latch can pop open; if it will not stay closed or rattles, the latch assembly should be replaced.

A problem with the sliding door track and door stops can allow the door to slide out of the track and fall off the vehicle. This is more common when doors are opened fast and allowed to hit the stops with a lot of force.

Timing cover oil and coolant leaks and front crankshaft oil seal leaks are common on high-mileage vehicles. Always replace the timing chain and cam sprocket at the same time.

A refrigerant leak at the rear AC expansion valve and/or AC evaporator seals may cause the rear AC not to work.

The rear lift gate support (prop) attaching bolts may break, causing the lift gate to fall unexpectedly. Thorough inspection of the bolts is required; if the support washers are loose, the supports need to be replaced.

Triggered by a short in the rear wiper motor/circuit (which causes a fuse to blow), the airbag warning light can illuminate erroneously.

Often when replacing the front left wheel speed sensor, the wrong part is used (it's from a later model year). If the wrong sensor is used, it can damage the wheel speed sensor wiring.
The transmission has numerous problems; symptoms can range from shuddering to completely dying. The majority of the TSBs (service bulletins) require an overhaul of the transmission. Updated internal parts are available. 
Due to corrosion at the pivot, the driver side window wiper may fail. The pivot must be replaced.
Windows may not roll up or down, resulting in a "ratcheting" noise. This is often caused by the plastic ribbon gear (flex tracks) on the regulator that breaks. Flex tracks are easily replaced by removing the door trim panel.