X

Lincoln Town Car Recalls

Models : Ford Crown Victoria, Lincoln Town Car, Mercury Grand Marquis
Suspension & Steering, November 5, 2014
RepairPal Expert Overview:

Certain vehicles are being recalled because the upper intermediate steering shaft could separate resulting in loss of steering control. This recall includes models previously recalled under campaign #13V-385, these vehicles may have been incorrectly repaired. Dealers will inspect and replace the upper immediate shaft if necessary. If the steering column lower bearing has separated, a retainer clip will be installed.

Models : Ford Crown Victoria, Lincoln Town Car, Mercury Grand Marquis
Suspension & Steering, August 29, 2013
RepairPal Expert Overview:

The intermediate shafts connect the steering column to the steering gear. Vehicles in areas where salt is used to de-ice the roads are being recalled because severe corrosion can damage the lower intermediate steering shaft. This can cause the upper intermediate shaft to collapse and separate at the lower steering column bearing. Separation will result in complete loss of steering ability. Dealers will replace the lower intermediate steering shaft and inspect the upper intermediate shaft and steering column lower bearing for damage, they will be repaired or replaced as necessary. If the steering column lower bearing has separated, a retainer clip will be installed.

Additionally, Vehicle owners located where salt is not used who have concerns regarding their steering will have a one-time option to have their vehicles inspected and, if necessary, repaired.

Summary:ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Models : Ford Crown Victoria, Lincoln Town Car, Mercury Grand Marquis
Suspension & Steering, June 22, 2007
RepairPal Expert Overview:

Improper heat treatment of the wheel bearing and hub assembly may allow the hub to fracture. If the hub fractures, the wheel will only be retained by the brake caliper assembly. If the wheel falls off while driving, a crash could result. Dealers will inspect and replace both front wheel bearing and hub assemblies free of charge. The recall began June 22, 2007. The Ford recall number is 07S54.

Models : Ford Crown Victoria, Lincoln Town Car, Mercury Grand Marquis
Electrical & Lights, November 18, 2005
RepairPal Expert Overview:

The battery cable includes a fusible link that may contact the #2 cross member. Over time, this contact could damage the fusible link. The damaged link could overheat and lead to a fire. Dealers will inspect the fusible link and position it away from the cross member. A damaged fusible link will be replaced. This recall is expected to begin on November 18, 2005. The Ford recall number is 05S38.

Models : Ford Crown Victoria, Lincoln Town Car
Suspension & Steering, July 15, 2004
RepairPal Expert Overview:

Vehicles subject to chassis overloading may experience premature rear wheel bearing failure. This could ultimately lead to axle shaft fracture. In the event of axle fracture, the vehicle would lose drive function and would coast to a stop. Loss of drive function could lead to a crash. Dealers will replace the wheel bearings, seals, and axle shafts to correct this concern. The Ford recall number is 04S16.

Models : Ford Mustang, Lincoln Town Car
Body, Interior & Misc., October 5, 2001
Summary:EQUIPMENT DESCRIPTION: PASSENGER VEHICLES THAT HAVE HAD THE DRIVER'S AIR BAG MODULE REPLACED AFTER APRIL 5, 2000. THE REPLACEMENT DRIVER'S AIR BAG MODULE INFLATOR MAY HAVE INSUFFICIENT WELDS THAT COULD PREVENT PROPER INFLATION OF THE AIR BAG.
RepairPal Expert Overview:

Ford has recalled certain 2000-2001 Excursion, Expedition, F150, F250, F350, Focus, Taurus, Mercury Sable, Lincoln Continental, Navigator, and Town Car vehicles due to a defect in the wiper motor gear case. The wiper motor could overheat and malfunction, which may cause the wipers to stop working as designed. Dealers will inspect the wiper motor and replace the gear case cover.

Summary:VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
Models : Lincoln Town Car
Drive Train, January 10, 2001
Summary:VEHICLE DESCRIPTION: CERTAIN LIMOUSINES STRETCHED OVER 60 INCHES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 109, "NEW PNEUMATIC TIRES," AND NO. 110, "TIRE SELECTION AND RIMS."