1994 Lincoln Town Car Problems

RepairPal has identified the most common problems with the 1994 Lincoln Town Car as reported by actual vehicle owners. We'll tell you what the problem is and what it'll take to fix it.

Refine by vehicle
×
Choose your vehicle
17
Known Problems

You may be able to prevent transmission problems by servicing the transmission and inspecting the fluid every 15,000 to 30,000 miles. If the fluid is dark or burned then the transmission fluid should be changed.

Checking and adjusting the AC compressor clutch air gap can extend the service life of the AC compressor.

Do not use air filters with oil-coated elements. They may cause premature failure of the mass air flow sensor; this is not covered under the warranty.

Sagging suspension can be a result of air suspension struts and/or drier leaking air. These type of air leaks can lead to failure of the air suspension compressor.

In high dust areas, problems with the EGR system are common. The filter for the EGR solenoid may plug and cause the EGR to activate when it should not; this can cause the engine to stall. The dirty filter should be replaced to correct this concern.

Erratic engine coolant temperature or intermittent overheating can be caused by corrosion inside the water pump. The impeller may spin on the water pump shaft or the impeller may corrode. Either condition reduces coolant circulation resulting in engine overheating.

 

Even though the manufacturer does not call for regular servicing, our technicians recommend servicing the power steering fluid regularly.

Corrosion can form at the grounding points near the battery. There may be electrical faults and the engine may crank but not start.

Check the battery cable ends frequently for corrosion. Corrosion can easily migrate under the cable insulation and cause numerous electrical faults and drivability issues.

When replacing the battery, make sure the battery height is correct; a battery that is too tall can cause a short circuit when the hood is closed.

An exhaust leak may develop in front of the catalytic converter. This type of leak should be corrected as soon a possible to avoid damaging the catalytic converter.

If you experience poor running and low fuel economy after the starter has been repaired, it could indicate that an incorrect starter relay was used. A diode-suppressed starter relay may be needed.
To extend fuel pump life, replace the fuel filter more often than the manufacturer recommends.

A vacuum leak from the PCV grommet vacuum leak can cause the Check Engine Light to illuminate. The molded rubber hose connections may crack and collapse, causing the vehicle to run roughly. A damaged PCV hose will require replacement.

The EGR tube may plug causing the EGR system to not function at all. As a result, engine pinging may be noted and the vehicle can fail mandated emissions testing.