Ford Recalls

Models : Ford Explorer
Engine, March 26, 1991
RepairPal Expert Overview:

Ford has recalled certain 1991 Explorer vehicles because the weld mounting the vapor vent valve to the top of the fuel tank could fracture, causing the vapor leak. Fuel vapor leaks could lead to a fire. Dealers will remove the fuel tank and inspect it for integrity. If the weld is found to be inadequate, the tank will be replaced.

Models : Ford Explorer
Body, Interior & Misc., March 26, 1991
RepairPal Expert Overview:

Ford has recalled certain 1991 Explorer vehicles for a possible issue with the rear bumper support. In some cases, the support could crack, resulting in a potential detachment of the bumper, which could cause injury. Dealers will install two brackets to secure the bumper reinforcement.

Models : Ford Probe
Body, Interior & Misc., March 25, 1991
Summary:BRACKETS MOUNTING AUTOMATIC SHOULDER BELT RETRACTOR ASSEMBLY MAY HAVE AN UNDERSTRENGTH SPOT WELD.
Models : Ford Crown Victoria, Ford Taurus, Lincoln Continental, Mercury Grand Marquis, Mercury Sable
Body, Interior & Misc., November 5, 1990
Summary:THREADED INFLATOR COMPONENTS MAY HAVE BEEN DAMAGED DURING ASSEMBLY WHICH MAY ALLOW COMPONENTS TO SEPARATE WHEN INFLATOR RECEIVES A SIGNAL TO DEPLOY THE AIR BAG.
Models : Ford Taurus
Drive Train, September 26, 1990
RepairPal Expert Overview:

Ford has recalled certain 1990 Taurus models with the police package installed. These vehicles have 14x5.5-inch steel wheels that could crack, causing a potential for the wheel rim to separate from the center. Dealers will replace affected wheels with a revised design.

Models : Ford Aerostar
Body, Interior & Misc., September 19, 1990
Summary:THE SECOND ROW RIGHT HAND SEAT ASSEMBLY HAS A TILT FORWARD FUNCTION. A LATCH RETAINS THE SEAT IN THE NORMAL RIDE POSTION, AND THIS LATCH MAY RELEASE UNDER SEVERE FRONTAL IMPACT CONDITIONS, ALLOWING THE SEAT TO PIVOT FORWARD.
Models : Ford E-150, Ford E-250, Ford E-350, Ford F-150, Ford F-250, Ford F-350
Drive Train, July 17, 1990
RepairPal Expert Overview:

Ford has recalled certain 1990 E and F Series 4x2 vehicles equipped with an E4OD transmission and a one piece driveshaft due to an issue with the park mechanism in the transmission. Some vehicles may experience a failure to engage the park gear, which can cause the vehicle to roll if the parking brake is not set. Dealers will replace the snap ring and install a revised extension housing

Models : Ford F-150, Ford F-250, Ford F-350
Brakes, July 17, 1990
RepairPal Expert Overview:

Ford has recalled 1990 F-Super Duty trucks and F-Super Duty Motor Home chassis because of the hydroboost steering gear return line plumbing. On certain vehicles, due to the routing of the return line, the hydroboost may stay engaged lightly, which may cause added brake wear and tear. Dealers will replace the return line and repair damaged brake components.

Models : Ford F-150, Ford F-250, Ford F-350
Brakes, June 20, 1990
RepairPal Expert Overview:

Ford has recalled certain 1990 F150-F350 trucks because the incorrect master cylinder was installed. The master cylinder installed is not large enough, which can inhibit braking force. Dealers will install the appropriate master cylinder.

Models : Ford Explorer
Body, Interior & Misc., May 9, 1990
RepairPal Expert Overview:

Ford has recalled certain 1991 Explorer vehicles because the sunroof assembly could detach from the mounting bracket and fall inside or off of the vehicle. This is due to improper fastening of the removable sunroof assembly upon re-installation. Dealers will replace the sunroof latch assemblies with latches that will secure the sunroof better.