Problems for specific Ford F-250 Super Duty years:

Car problem reports

Report A Problem

Problem with your car? See what our experts say or submit your own.

Newest reported 2002 Ford F-250 Super Duty problems

 

Verified for the Ford F-250 Super Duty

An oil leak may develop from the the right side head gasket.  Oil from this type of leak will commonly drip onto the starter. Our technician tell us an updated head gasket is available to correct this concern.

14 Reports
Me Too

Verified for the Ford F-250 Super Duty

A defective idler pulley and / or belt material can cause a chirp or squeak noise from the engine area on initial start up. The idler pulley and / or belt will need to be replaced with revised parts.

11 Reports
Me Too

Verified for the Ford F-250 Super Duty

There is a technical service bulletin for the V8 engines regarding a possible problem with the spark plug being ejected from the cylinder head, damaging the threads in the spark plug hole. If the vehicle is under warranty, cylinder head replacement is recommended. If the vehicle is out of warranty, Ford authorized the use of a specific thread insert to repair the head.

23 Reports
Me Too

Verified for the Ford F-250 Super Duty

An illuminated Check Engine Light could indicate that one or more of the ignition coils has failed due to excessive spark plug gap. To fix this problem, the ignition coils that have failed, the spark plugs, and all coil boots should be replaced.

9 Reports
Me Too

Verified for the Ford F-250 Super Duty

Delamination of the diesel fuel tank can occur resulting in a loss of power due to debris clogging the fuel filters. In some cases the fuel injection pump and/or fuel injectors have also been damaged. Ford has issued a service bulletin (#19728) addressing this concern.

19 Reports
Me Too

Verified for the Ford F-250 Super Duty
Using the correct oil for this engine is critical. Improper engine oil can foam in the high pressure system and not develop enough pressure for operation. Symptoms of this can be hard starting, long cranking time before start, rough engine idle, and a lack of power. Another sign is tiny bubbles in the oil on the engine oil dipstick after the engine is shut off. The additives in the correct oil that protect against foaming can still break down, so changing the oil at the correct intervals is important.
5 Reports
Me Too
Ask a Question