4x4 Automatic 4x4 Low 4x4 high Light did not Appear in the dash board. Just Replaced The 4x4 Control Module your Problems solve.
Problems for specific Ford Explorer years:
Car problem reports
Problem with your car? See what our experts say or submit your own.
Newest reported 2002 Ford Explorer problems
A rattling noise from the engine may indicate that the timing chain cassette is worn. Our technicians tell us that installing an updated cassette and timing chain tensioner should correct this concern.
The rear window wiper may not fully contact the rear window. Our technicians tell us that replacing both the wiper blade and wiper arm will generally correct this issue.
Rear diferential making loud whining noises at higher speeds. pinion and ring gear were replaced, happened on my 99 Explorer too
The intake manifold O-ring gaskets commonly leak, causing stalling and poor idle quality; the Check Engine Light will illuminate.
A failed heater blend door or actuator can cause the temperature control for the HVAC system to stop working. A clicking sound from the dash area would commonly indicate an actuator fault. If the heater gets stuck on the hottest setting, the heater blend door may be broken requiring replacement of the heater box to repair the issue.
The rear wiper may stop working. This could be due to a rear wiper motor that has failed requiring replacement.
Various problems with the 5-speed automatic transmission were common. These problems can be more common on the 2002 models with build dates before March, 2002. There are many service bulletins describing the diagnoses and repairs, which include fluid leak repairs, transmission software updates, or internal failures requiring a costly repair.
A cosmetic crack may develop on the plastic liftgate trim panel. Ford has released a service procedure to replace the applique without damage the the liftgate glass.
The composite (plastic) intake manifold may crack near the thermostat housing and cause a coolant leak. Ford released an updated manifold that was reinforced to prevent a recurrence. No recall was issued for this problem but Ford did extend the warranty to seven years on some models from the date of purchase.
Both V6 and V8 ford engines from various years sometimes experience a very loud low pitched moan or howl that sounds as if it is coming from the air intake area..
The culprit is the Idle Air Control Valve. (I.A.C.).
It is possible to remove and clean the IAC with the proper care but it is not advised to do so...Although it may work for a short time, it will eventually fail again and possibly force you to call a towing service when you le...