1997 Ford Aerostar Problem Reports

Newest 1997 Ford Aerostar Problem Reports

Report A Problem

Bad throttle position sensors can cause high idle without causing the Check Engine Light to illuminate.

The synchronizer shaft for the camshaft position sensor can cause a loud squeak or chirping noise due to failure of the upper bushing. The noise may be erratic and is usually present when the engine is warm.

If you experience poor idle quality and fuel economy (and the Check Engine Light illuminates) after the exhaust system or motor has been removed and replaced, it could be that the oxygen sensor wires are crossed at the rear of the motor. Wiring schematics should be checked to ensure that the correct harness plug is connected to the corresponding sensor.


Engine oil leaks are known to develop around the rear crankshaft (main) seal and engine oil pan gasket.

Ignition module failure is common and causes a "No start" condition or intermittent stalls.