» » »

Problems for specific Dodge Grand Caravan years:

Car problem reports

Report A Problem

Problem with your car? See what our experts say or submit your own.

Newest reported 1996 Dodge Grand Caravan problems

 

Verified for the Dodge Grand Caravan

A delay in the transaxle engagement (greater than three seconds) may have multiple causes, including a defective pump, defective internal lip seals, valve body components, park-reverse-neutral-drive lever switch, and the output speed sensor. Proper diagnoses will be necessary to determine the exact cause.

7 Reports
Me Too

Verified for the Dodge Grand Caravan

Illuminated of the airbag warning light may be caused by a lost connection between the clockspring (behind the steering wheel) and the steering wheel-mounted electrical components. Other steering wheel-mounted controls like the horn, speed (cruise) control, or radio controls (if equipped) may be inoperative. There is a lifetime warranty on the clockspring as specified in a combination of recall campaigns. For more information on these recalls please us the following links; 1996-1998 models, please click here». For 1998-2000 models, please click here»

12 Reports
Me Too

Verified for the Dodge Grand Caravan

AWD equipped vehicles can show a wide range of transmission problems, often caused by using the wrong-sized and/or mismatched tires. Be sure that all the tires are the same and that all four are replaced at the same time. Dodge recommends tire rotation every 7,500 miles.

7 Reports
Me Too

Verified for the Dodge Grand Caravan

A momentary loss of power steering can occur when the AC or defroster is on during high humidity conditions. This is due to condensation from the evaporator draining onto the serpentine belt.  To fix the problem, a spout on the AC evaporator drain and a new serpentine belt should be installed. Some vehicles may need a revised serpentine belt tensioner.

5 Reports
Me Too

Verified for the Dodge Grand Caravan

There have been reports of premature head gasket failure; an updated gasket design is available to correct this problem.

2 Reports
Me Too

Verified for the Dodge Grand Caravan

On higher-mileage vehicles, engine oil leaks from the valve covers and front crankshaft seal are common.

2 Reports
Me Too

Verified for the Dodge Grand Caravan

If the door lock actuators (integrated into the door latch assembly) are noisy and/or not working, the latch should be replaced. For some model years, the actuator for the sliding door is available separately from the latch.

8 Reports
Me Too

Verified for the Dodge Grand Caravan

A malfunctioning switch in the steering column can cause the front windshield wipers to self-activate or not turn off. A failed windshield switch will require replacement.

7 Reports
Me Too

Verified for the Dodge Grand Caravan

A bad ground on the left frame rail can cause intermittent operation of the radiator cooling fans or AC compressor.

1 Report
Me Too

Verified for the Dodge Grand Caravan

Some vehicles may develop a musty odor coming from the HVAC system, Dodge has issued a cleaner/disinfectant and a coating for the evaporator designed to inhibit bacterial growth.

53 Reports
Me Too

Verified for the Dodge Grand Caravan

When braking during low speeds (under 10 MPH), the brake pedal may vibrate and the ABS hydraulic unit may cause a rumbling noise. This is caused by a momentary loss of the wheel speed signal to the ABS controller. Adjusting or replacing the wheel speed sensor will commonly fix this problem.

8 Reports
Me Too

Verified for the Dodge Grand Caravan

Timing cover oil and coolant leaks are common, the oil and coolant don't normally mix. Our technicians recommend to replace the timing chain and cam sprocket if the timing cover is removed to reseal - or for any other reason.

10 Reports
Me Too

Verified for the Dodge Grand Caravan

Hood misalignment, cowl cover misalignment, wiper module drain tube(s), and/or the lower plenum drain hose may cause the HVAC housing to leak water onto the passenger side floor. Diagnoses will be required to confirm the location of a water leak in the front passenger area.

13 Reports
Me Too

Verified for the Dodge Grand Caravan

Spark plug tube seals fail, causing the tubes to fill with engine oil and the engine to misfire. As a result, the engine may run poorly and fuel economy can suffer.

2 Reports
Me Too

Verified for the Dodge Grand Caravan

The rear lift gate support (prop) attaching bolts may break, causing the lift gate to fall unexpectedly. Thorough inspection of the bolts is required; if the support washers are loose, the supports need to be replaced.

17 Reports
Me Too
Ask a Question