» » »

Problems for specific Dodge Grand Caravan years:

Car problem reports

Report A Problem

Problem with your car? See what our experts say or submit your own.

Newest reported 1991 Dodge Grand Caravan problems

 

Verified for the Dodge Grand Caravan

A defective anti-lock brake system (ABS) pump and/or leaking piston seals in the master cylinder can cause excessive pedal effort, lack of stopping power, and abnormal pump noise. Diagnoses will be required to determine the root cause of any braking issues and the component(s) that will require replacement.

4 Reports
Me Too

Verified for the Dodge Grand Caravan

The speedometer may become inoperative due to a failed vehicle speed sensor (VSS), . A failed sensor will require replacement.

6 Reports
Me Too

Verified for the Dodge Grand Caravan

The door ajar light may illuminate and chime during driving, even when the sliding door is closed. Often, this is caused by a faulty switch in the C-pillar; a revised switch is available.

10 Reports
Me Too

Verified for the Dodge Grand Caravan

Voltage spikes can cause erratic behavior in the electrical system (lights, locks, wipers, head lamps). This is often caused by relays. Inspection and replacement  of relays is required; revised relays are available.

3 Reports
Me Too

Verified for the Dodge Grand Caravan

The airbag warning light may remain illuminated while the ignition switch is in the "on" position. This can be caused by water that has entered into the airbag six-way connector in the engine compartment.

3 Reports
Me Too

Verified for the Dodge Grand Caravan

Sometimes the vent windows' latch can pop open; if it will not stay closed or rattles, the latch assembly should be replaced.

6 Reports
Me Too

Verified for the Dodge Grand Caravan

Carbon buildup on the top of the piston is common. Over time this can lead to symptoms varying from light ticking to knocking noises. Performing a fuel injector cleaning procedure can often help the condition by removing some of the piston top deposits.

2 Reports
Me Too

Verified for the Dodge Grand Caravan

A refrigerant leak at the rear AC expansion valve and/or AC evaporator seals may cause the rear AC not to work.

7 Reports
Me Too

Verified for the Dodge Grand Caravan

The rear lift gate support (prop) attaching bolts may break, causing the lift gate to fall unexpectedly. Thorough inspection of the bolts is required; if the support washers are loose, the supports need to be replaced.

14 Reports
Me Too

Verified for the Dodge Grand Caravan

A problem with the sliding door track and door stops can allow the door to slide out of the track and fall off the vehicle. This is more common when doors are opened fast and allowed to hit the stops with a lot of force.

23 Reports
Me Too

Verified for the Dodge Grand Caravan

Triggered by a short in the rear wiper motor/circuit (which causes a fuse to blow), the airbag warning light can illuminate erroneously.

6 Reports
Me Too

Verified for the Dodge Grand Caravan
Often when replacing the front left wheel speed sensor, the wrong part is used (it's from a later model year). If the wrong sensor is used, it can damage the wheel speed sensor wiring.
4 Reports
Me Too

Verified for the Dodge Grand Caravan

Timing cover oil and coolant leaks and front crankshaft oil seal leaks are common on high-mileage vehicles. Always replace the timing chain and cam sprocket at the same time.

2 Reports
Me Too

Verified for the Dodge Grand Caravan
An intermittent loss of speed control can happen soon after the transaxle input or output speed sensor has been replaced. The problem is most likely caused by bad connectors.
6 Reports
Me Too

Verified for the Dodge Grand Caravan
An improperly-seated connection on the starter (coming from the battery) may cause the engine not to crank. Plastic must be ground off the cable terminal so it can sit flat and flush.
6 Reports
Me Too
Ask a Question