2001 Dodge Caravan Problems
RepairPal has identified the most common problems with the 2001 Dodge Caravan as reported by actual vehicle owners. We'll tell you what the problem is and what it'll take to fix it.Refine by vehicle
A failing head lamp switch can cause the head lamps and/or instrument cluster lighting to flicker or dim. The head lamp switch should have a noticeable click between each position; a "mushy" feel is a strong indication of a failing switch.
Coolant leaks coming from the underbody on vehicles equipped with rear heat/AC are common. The underbody hoses should be inspected as part of regular maintenance. If you drive on roads where salt is prevalent the problem is generally more severe. Some 2005 models are involved in a special service action, no government recall was issued.
An oil leak from the oil filter adapter may be evident. Dodge has made a revised oil filter adapter is available.
If the HVAC (heater) housing is not properly sealed at the bulkhead (firewall), water can leak into the passenger compartment. Foam sealant should be used to seal any gaps and the evaporator drain tube can be modified to prevent further water entry.
Due to a lack of lubrication, the AC compressor can fail. The AC compressor warranty was extended to seven years or 70,000 miles.
Intermittently, the key may not start the car or release from the ignition. If it is excessively worn, replace the key. If the new key doesn't work, replacing the lock cylinder including tumblers should correct this concern.
A dirty throttle body may cause low engine idle speed or frequent stalling, as oily residue blocks air flow in the throttle when the throttle is closed. Throttle body cleaning may be necessary to correct this condition. Our technicians caution against spraying cleaner directly onto the throttle body as this may damage the throttle position sensor (TPS).
The door ajar light may illuminate and chime during driving, even when the sliding door is closed. Often, this is caused by a faulty switch in the C-pillar; a revised switch is available.
AWD equipped vehicles can show a wide range of transmission problems, often caused by using the wrong-sized and/or mismatched tires. Be sure that all the tires are the same and that all four are replaced at the same time. Dodge recommends tire rotation every 7,500 miles.
While turning in either direction during low speed parking lot maneuvers, if a creaking, squawking, squeaking, grinding, or groaning sound is heard from the front strut area, locate the front strut dust boot and rotate the dust boot side to side. If the sound is present, applying lubricant to the jounce bumper (bump stop) of both front struts can help with the noise.