Car Problem Reports

Volvo S60 Coolant Leak From Front due to Leaking Radiator

 
Volvo S60 Problem
15 Reports
Me Too
Edit

Model Years Affected: 2002, 2003, 2004, 2005

Engines Affected: 2.4L 5 Cylinder, 2.4L 5 Cylinder Turbo, 2.5L 5 Cylinder Turbo, Turbo

Average Mileage: 103,995 mi (41,000 mi - 170,000 mi)

Verified

Coolant leaking from the front of the vehicle is often due to a leaking radiator, which must be replaced.

  • Visitor, , 2.4L 5 Cylinder, 170,000 mi

    My 2003 volvo is leaking coolant its getting worse.I am repalcing coolant every 2 days

    Flag This
  • Visitor, , 2.5L 5 Cylinder Turbo, 100,000 mi

    Started leaking about 100000 miles, but it was very small and I did not repair it for 18 months. We were going on a long trip so I finally replacedd the radiator at 109000 miles

    Flag This
  • Visitor, , Turbo, 41,000 mi

    slow leak, and reported that I need to replace radiator (after they put a 85lb block on engine/radiator to test leak)

    Flag This
  • Visitor, , 2.4L 5 Cylinder Turbo, 100,350 mi

    the radiator has a crack where the hose the hose attaches from the motor

    Flag This
  • Visitor, , 2.5L 5 Cylinder Turbo, 95,600 mi

    Radiator Leaking. Replaced by dealership. $900.

    Flag This
  • Visitor, , 2.5L 5 Cylinder Turbo, 117,000 mi

    replaced radiator

    Flag This
  • Visitor, , 2.5L 5 Cylinder Turbo, 112,000 mi

    I brought my 2003 volvo s60 awd to the dealership for a recall on my fuel pump that was extended to 150,000 miles for this make and other years not sure which other years are covered. They ended finding other things wrong of course you go in for something free they find something else to bill you especially since I needed my inspection sticker to pass. Well after I agreed to do my bushing on both my front control arms. I also paid for a fuel sensor which I thought was reasonably being they were not charging me for labor. They also said I had a leak in my radiator which just the radiator for volvo is $700 dollars not including labor. Well trying to swallow that one but I already see after I change this fuel pump on this mercedes today. I will be getting into another new project. Volvo isn't a race car someone explain why they would use aluminum and plastic for material like a radiator. "Just to hurt our pockets" Nissan does the samething with there cars Nissan quest has a serpentine chain yea sounds stronger than a belt right wrong the guard that holds it in is made out of PLASTIC! GOOD LUCK GUYS!

    Flag This
  • Visitor, , 2.5L 5 Cylinder Turbo, 156,000 mi

    Leak in radiator at the passenger side must remove plastic shield under car to diagnose and localize the exact source of the leak. Radiator needs replacement to remedy the problem.

    Flag This
Ask a Question