Worn sway bar bushings or sway bar end links may cause a rattling or clunking noise from the front suspension during low-speed driving. Though not always the root cause, front struts are often replaced for this condition.
2001 Chrysler Town & Country Problem Reports
RepairPal Verified 2001 Chrysler Town & Country Problem Reports
A failing head lamp switch can cause the head lamps and/or instrument cluster lighting to flicker or dim. The head lamp switch should have a noticeable click between each position; a "mushy" feel is a strong indication of a failing switch.
Illuminated of the airbag warning light may be caused by a lost connection between the clockspring (behind the steering wheel) and the steering wheel-mounted electrical components. Other steering wheel-mounted controls like the horn, speed (cruise) control, or radio controls (if equipped) may be inoperative. There is a lifetime warranty on the clockspring as specified in a combination of recall campaigns. For more information on these recalls please us the following links; 1996-1998 models, please click here». For 1998-2000 models, please click here»
AWD equipped vehicles can show a wide range of transmission problems, often caused by using the wrong-sized and/or mismatched tires. Be sure that all the tires are the same and that all four are replaced at the same time. Dodge recommends tire rotation every 7,500 miles.
If the HVAC (heater) housing is not properly sealed at the bulkhead (firewall), water can leak into the passenger compartment. Foam sealant should be used to seal any gaps and the evaporator drain tube can be modified to prevent further water entry.
On higher-mileage vehicles, engine oil leaks from the valve covers and front crankshaft seal are common.
Due to a lack of lubrication, the AC compressor can fail. The AC compressor warranty was extended to seven years or 70,000 miles.
While turning in either direction during low speed parking lot maneuvers, if a creaking, squawking, squeaking, grinding, or groaning sound is heard from the front strut area, locate the front strut dust boot and rotate the dust boot side to side. If the sound is present, applying lubricant to the jounce bumper (bump stop) of both front struts can help with the noise.
If the heater is on and no heat is felt from the right side dash vents, there may be a problem with the blend air door shaft; a revised part is available to address this concern.
V6 engines may experience surging while driving. The condition is more noticeable between 40 and 50 MPH while accelerating up a hill/slight incline. Replacing the powertrain control module (PCM) and updating the transmission control module (TCM) software may be required.
An oil leak from the oil filter adapter may be evident. Chrysler has made a revised oil filter adapter is available.
Excessive oil consumption—defined as more than one quart per 1,000 miles (on vehicles with less than 50,000 miles) or more than one quart per 750 miles (on vehicles with more than 50,000 miles)—is common. Common causes include exhaust valve guides, valve cover gaskets, camshaft plugs, camshaft seals, and crankshaft seal.
A moaning or fog horn sound may be heard while turning at a slow speed. Installing a finned power steering cooler will help alleviate the problem, but it may be necessary to replace the power steering rack.
Misalignment of the accessory pulleys or a faulty drive belt tensioner may cause a chirping or squeaking sound while the engine is running. In If the replacing the belt tensioner does not correct the noise, the alternator pulley may require replacement.