Problems for specific Chevrolet 2500 Pickup years:

Car problem reports

Report A Problem

Problem with your car? See what our experts say or submit your own.

Newest reported 1992 Chevrolet 2500 Pickup problems

 

Verified for the Chevrolet 2500 Pickup

The distributor may develop internal faults. This can cause a rough running engine or stalling condition, the Check Engine Light may or may not illuminate. Our technicians tell us that the distributor should be overhauled or replaced to correct this concern.

7 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

The intake manifold gasket may develop and external engine oil or coolant leak. In some cases, an internal coolant leak may occur causing coolant to mix with the engine oil. Our technicians tell us that operating the engine  with a coolant/oil mix can result in internal engine damage. Replacing the intake manifold gasket should correct these leaks.

23 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

The alternator may fail causing the battery to go dead, or an abnormal noise may develop. The dash warning light may or may not illuminate. A failed alternator will require replacement.

6 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

Power brake systems using "hydro-boost" may leak power steering fluid from the hydro-boost unit located behind the brake master cylinder. Replacement of the hydro-boost unit is the common repair to correct this concern.

16 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

One or more heater & AC (HVAC) air delivery and/or temperature mode door actuator may fail. This can result in incorrect air delivery or temperature. If this occurs, fault code(s) stored in the HVAC control module should be available to assist with diagnoses.

6 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

The quick-connect fittings for the heater hoses tend to leak engine coolant. This problem commonly occurs because the metal housing has become brittle, which can break and cause leaks.

15 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

The air conditioning compressor may develop an abnormal noise and require replacement. We recommend that whenever an AC compressor is being replaced for a noise condition, a filter kit should be installed to prevent any metal particles in the system from damaging the new compressor.

12 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

An oil leak may develop from the distributor o-ring seal requiring replacement of the seal.

6 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

The power door lock actuators may become slow to operate or stop working completely and require replacement.

13 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

The anti-lock brake system (ABS) front wheel speed sensors are prone to failure. When a sensor fails, the ABS warning light may illuminate and/or the ABS system may activate erratically.

14 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

The throttle body gasket may develop a vacuum leak which may result in a higher than normal engine idle. Failed gaskets will require replacement.

12 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

A coolant leak may develop from the water pump. The engine may overheat as a result of the coolant loss. A leaking water pump should be replaced.

12 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

The windshield wipers may not work intermittently due to a faulty wiper motor control board. Our technicians tell us that lightly taping on the wiper motor when the fault occurs should temporarily get the wipers working again. Some vehicles were recalled for this problem and some were not. You will need to check with your local dealer to find out if a specific vehicle was included.

18 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

The fuel pump may fail causing the engine to stall and not restart. Our technicians recommend replacing the fuel filter every 30,000 miles to help prevent undue strain on the fuel pump.

14 Reports
Me Too

Verified for the Chevrolet 2500 Pickup

The inside and outside door handles are prone to breaking.

20 Reports
Me Too
Ask a Question