» » » 1994

Resources for the Repair and Maintenance of your 1994 Volvo 960

1994 Volvo 960

Image for car images Volvo 1992 1997 Volvo 960 size thumb

1994 Volvo 960 Problems

Suspension & Steering -- Verified

The sway bar bushings commonly wear out, causing a knocking noise from the front of the vehicle. Replacing the worn bushings should correct this concern.

Suspension & Steering -- Verified

The front control arm bushings wear out, resulting in alignment issues and squeaking and/or knocking noises from the front end. Worn bushings will require replacement.

Engine -- Verified

The intake manifold gasket will often be a source of vacuum leaks. This will cause a rough idle and the Check Engine Light will illuminate. Replacement of the gasket is required to resolve this issue.

Drive Train -- Verified

The gear position sensor on the transmission may fail, resulting in illumination of the Check Engine Light and/or a no start condition.

Brakes -- Verified

Vibration problems from the rear brake rotors are common and require replacement of the pads and rotors, and the installation of special shims. The symptoms often occur when the brakes are used heavily from repeated braking, braking from high speeds, and braking while going downhill. The entire vehicle can vibrate and shudder, like it is being driven over train tracks.

1994 Volvo 960 Questions and Answers

odonnell, 1994 Volvo 960, Newport, RI

I inherited the car, no idea about prior maintenance. Sometimes starts right up, but often after being driven takes 10 -20 minutes before starts. I also do not have an owners manual.

infarto, 1994 Volvo 960, Dallas, TX

how much to replace heater core ?parts and labor?

voljoe, 1994 Volvo 960, 2.9L 6 Cylinder, Knoxville, TN

My airconditioning system does not work effectively. It is fully gassed up, but the compressor seems to be cutting in and out, I suspect it is my outside sensor. The inside of the car gets too hot ...

Visitor, 1994 Volvo 960, 2.9L 6 Cylinder, Overland Park, KS

When I am driving, all the dashboard lights come on and the car loses all power. I pull over and it starts right back up. Sometimes it does this two or three times a day and sometimes not at all. A...

lee Brooks, 1994 Volvo 960, 2.9L 6 Cylinder, Portland, OR

I ordered a replacement mirror (glass only) for the existing one fell out. I received it and it has a plastic back with two electrical polls for the heater.

My question is how do I remove the old...

Write a Review About Your Car

1994 Volvo 960 Reviews

my engine light wont go off why? my air conditioning dont work ,the heating is fine ? also i have to keep check the oil,and keep puting oil in?away from what is say the car run well,last week i hit a bad pot hole and blow two tires on the left side and now the gas gauge not well sometim it look like there is no gas in there but i knwo that there is gas in . .Are you in staten Island and where is your shop?

Recent Repair Estimates