» » » 2004

Resources for the Repair and Maintenance of your 2004 Pontiac Aztek

2004 Pontiac Aztek

Image for car images Pontiac 2001 2005 Pontiac Aztek size thumb

2004 Pontiac Aztek Problems

Engine -- Verified

The intake manifold gasket may develop and external engine oil or coolant leak. In some cases, an internal coolant leak may occur causing coolant to mix with the engine oil. Our technicians tell us that operating the engine  with a coolant/oil mix can result in internal engine damage. Replacing the intake manifold gasket should correct these leaks.

Exhaust & Emissions -- Verified

Illumination of the Check Engine Light can be caused by a loose or worn gas cap.

Suspension & Steering -- Verified

The high pressure power steering hose will commonly leak fluid and should be replaced if this is the case.

Engine -- Verified

A coolant leak may develop from the water pump. The engine may overheat as a result of the coolant loss. A leaking water pump should be replaced.

Brakes -- Verified

Front brake rotors can wear causing a pulsation felt in the brake pedal. Our technicians often recommend replacement of the front rotors and brake pads as the best option to correct this condition.

2004 Pontiac Aztek Recalls (Recent)

Drive Train, May 4, 2005

RepairPal Expert Overview:

Contamination of the ignition relay contacts may cause high resistance inside the relay. This can affect signals to the powertrain control module, resulting in intermittent vehicle stalling. The vehicle may not restart immediately, increasing the risk of a crash. Dealers will replace the ignition relay to correct this concern. This recall is scheduled to begin during May 2005. The General Motors recall number is 05014.

Learn more »

Engine, December 4, 2007

RepairPal Expert Overview:

Due to variations in the manufacturing process, or exposure to high heat may lead to a fracture in the tank inlet check valve. Fuel vapors may pass through the fracture and accumulate on the side of the fuel tank. A fuel leak in the presence of an ignition source could result in a fire. Dealers will replace the fuel tank. The recall began December 4, 2007. The GM recall number is 06230.

Learn more »

Engine, November 4, 2003

RepairPal Expert Overview:

On 79 vehicles, a weld between the fuel tank inlet check valve and the fuel tank can fail. As a result, a fuel odor or leak could develop and/or the Check Engine Light could illuminate. Any fuel leak always increases the risk of a fire. Dealers will inspect the fuel tank by serial number and replace it if it's on the list of affected fuel tanks. The recall began during November 2003. The General Motors recall number is 03055.

 

Learn more »

2004 Pontiac Aztek Questions and Answers

pc_mekanic, 2004 Pontiac Aztek, Neenah, WI

Recently my A/C blower has been kicking off for no reason. It won't run at any speed setting (low, med, or high). Then, out of the blue, it will just kick back on again. It may work for a f...

3lilmonkies, 2004 Pontiac Aztek, Huntington, WV

We know how to change a fuel pump, but we are having a hard time getting the gas tank off. We have unbolted and removed straps to no avail. We need to be able to drop the tank so we can change the ...

stevebrad92, 2004 Pontiac Aztek, 3.4L V6, Memphis, TN

p0641 high idle.3000rpm cold and 2000rpm when engine is hot after a week you now have to let off the gas to get trans to shift.it will go 45 mph without touching the gas

stevebrad92, 2004 Pontiac Aztek, 3.4L V6, Memphis, TN

idle is at 3000rpm in park,run 45mph without touching the ggas and have to let off the gas to let trans shift.engine runs great going down the road

stevebrad92, 2004 Pontiac Aztek, 3.4L V6, Memphis, TN

sometimes it idles fine when it idles fast you can unplug mass air flow sensor no change but when its idle right you unplug the sensor and it idles fast does this mean the mass air flow sensor is bad?

Write a Review About Your Car

2004 Pontiac Aztek Reviews

I absolutely love my car. It gets great gas mileage, drives well even in the snow, and has never given me any problems. My only complaint is the spoiler on the back window that can create a visual problem, but you adjust to it.

Great car. Wouldn't trade it.

I own a 2004 Pontiac Aztec. I love the body and inside design. However!!, I have had the most electrical and ignition problems. I can not read the odometer, radio settings nor does the gear shift light works. I have been told that a new fuse will not fix the problem but that someone will have to go behinde the panel to fix the problem. The motor in the window stopped working and the window will not let down. Also, I have had the ignition switched replaced twice (2009 & 2012) and the stearing colume has been replaced once, with the first ignition replacement. The key sticks and the last time the ignition switch was replaced because the car would not turn off. Although, I have a new switch and key, the key still sticks!! And yeah, at times it is difficult to put the gear in reverse,OMG, not the transmission. How can I fix the lights and what may be the cause of the other problems?

2004 Pontiac Aztec, everyone laughed at the shape...My kids called it the geometrical object.
I have 212,122 miles on it and not that many problems. I have put brake pads on about 5 times. It's good in all weather. Condensation gets in headlamps have replaced 2 or 3. It's
security system locked me out due to a blown fuse and had to be towed to the nearest dealer-my radio said that the vehicle had been locked. The alternator was replaced while on warranty
I have been on this site to see if any one has had a transmission problem?.

Recent Repair Estimates