Mercedes-Benz G55 AMG Repair and Maintenance - Get an online auto repair estimate for your Mercedes-Benz G55 AMG

RepairPal gives you independent and unbiased repair estimates, user
ratings and reviews, plus advice you can't get anywhere else.

It's easy, accurate, and FREE!

Find out what your auto repair should cost

Mercedes-Benz G55 AMG Repair and Maintenance

Image for Mercedes Benz 2002 2006 Mercedes Benz G500

» Back to top
Mercedes-Benz G55 AMG Problems

Brakes
  • Soft braking compounds that contribute to good braking performance are known to wear after approximately 20,000 miles; owners should be vigilant about getting their brakes checked.
  • Brake fluid should be flushed every two years to prevent premature anti-lock brake system (ABS) failure.
Engine
  • Oil leaks from the PCV vent housings on the valve covers and inspection plates on the front of the engine are common.
  • The rubber bond in the harmonic balancer can decay, which causes the balancer to move and work its way into the timing chain cover. If the balancer comes into contact with the timing cover while the engine is running, it will fracture and damage the timing case and potentially other surrounding parts. The harmonic balancer should be inspected at every service.
  • Oil leaks from the oil level sensor are common.
  • The crankshaft position sensors tend to fail. Symptoms of this are: The engine will crank—but not start—especially when the engine is warm. The car may start again if it is left to cool off, but it may run roughly or have poor performance. Communicating these specific symptoms to your technician can save diagnostic time.
Drive Train
  • The wire connector on the transmission leaks fluid into the wiring harness. If not repaired, the oil will migrate through the wiring harness and damage the transmission control module. A new harness and control module are required to fix the problem.
  • Axle lubrication should be performed at each service; the hydraulic fluid in the differential lockers should be changed every two years.
Electrical & Lights
  • Brake light switch failure can cause the ESP and BAS warnings to illuminate.
  • Due to the location of the ABS hydraulic unit on the inner fender, the connector (or wires) for the brake pressure switch can be damaged when the connector rattles or chafes against the inner fender. This problem will illuminate the ESP warning light.

» Back to top
Mercedes-Benz G55 AMG Recalls and TSBs

Mercedes-Benz G55 AMG Recalls (Recent)

Electrical & Lights: ELECTRICAL SYSTEM
Campaign Number: 08V303000
Dates Manufactured: 11/2002 to 05/2008
Number of Vehicles Affected: 404
Model Years Affected: 2003

Defect Summary: MERCEDES-BENZ IS RECALLING MY 2006-2008 M-CLASS, R-CLASS, MY 2005-2009 SLK-CLASS, MY 2005-2008 C-CLASS, MY 2003-2004 AND 2006-2008 CLK-CLASS, MY 2003-2008 E-CLASS, MY 2004 AND 2008 CL-CLASS, MY 2008 CLS-CLASS, MY 2004 AND 2007-2008 S-CLASS, MY 2003 G-CLASS, AND MY 2003-2004, 2006 AND 2009 SL-CLASS VEHICLES. A SOFTWARE CALIBRATION NUMBER (SCN) CODING RECEIVED ON THE AFFECTED VEHICLES DURING A RECENT WORKSHOP VISIT WAS INCORRECT. DEPENDING ON THE MODEL YEAR AND MODEL AFFECTED, THE RESULTS OF AN INCORRECT SCN CODING CAN AFFECT A NUMBER OF VEHICLE SAFETY AND EMISSION FUNCTIONS INCLUDING THE FOLLOWING TYPES OF FUNCTIONS: (1) THE FUEL GAUGE READINGS MAY BE INCORRECT; (2) A STUCK FUEL-LEVEL SENSOR MAY NOT BE DISPLAYED IN THE INSTRUMENT CLUSTER; (3) THE OBD SYSTEM MAY CAUSE THE CHECK ENGINE LIGHT TO ILLUMINATE INCORRECTLY; AND, (4) THE SPEEDOMETER MAY BE OUT OF TOLERANCE.

Consequence Summary: IN THE EVENT OF A VEHICLE CRASH, THE ELECTRICAL FUEL PUMP MAY NOT RECEIVE A CRASH SIGNAL THAT IS REQUIRED FOR THE FUEL PUMP TO DISCONNECT AND PREVENT FUTURE FUEL DELIVERY AS DESIGNED.

Corrective Summary: DEALERS WILL RECODE THE SCN FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2008. OWNERS MAY CONTACT MERCEDES-BENZ AT 1-800-367-6372.

Recall Notes: MERCEDES-BENZ RECALL NO. 2008 070001.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Engine: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Campaign Number: 05V378000
Dates Manufactured: 04/2005 to 04/2005
Number of Vehicles Affected: 487
Model Years Affected: 2004, 2005
Date Owner Notified: 09/2005

Defect Summary: ON CERTAIN SPORT UTILITY VEHICLES, THE FUEL RETURN HOSE BETWEEN FUEL TANK AND RETURN LINE CAN BE PERMEATED WITH FUEL. THIS SITUATION RESULTS FROM THE EXPANSION AND CONTRACTION OF THE HOSE UNDER PRESSURE CAUSING MICROCRACKS IN THE HOSE MATERIAL.

Consequence Summary: THESE MICROCRACKS MAY CAUSE FUEL LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Corrective Summary: DEALERS WILL INSPECT AND REPLACE ALL FUEL RETURN HOSES WITH THE APPROPRIATE HOSES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 27, 2005. OWNERS MAY CONTACT MERCEDES BENZ AT 1-800-367-6372.

Recall Notes: MERCEDES-BENZ RECALL NO. 2005080007.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION¿S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

» Back to top

Mercedes-Benz G55 AMG Technical Service Bulletins (Recent)

None reported.

 

 Find the right shop for your G55 AMG
The best shops near you - with ratings and reviews
(City and State or Zip)
Get inside info about your G55 AMG
Common problems and Q&A
Recalls, ratings & reviews
Track your G55 AMG's service
Keep everything online in one place. Get service reminders

Recent Mercedes-Benz Repair Estimates

Brake Pad(s) Replacement
2010 Mercedes-Benz G55 AMG in Los Angeles, CA
$136 - $223
Exhaust Manifold Gasket(s) Replacement
2009 Mercedes-Benz G55 AMG in Glendale, CA
$538 - $681
Maintenance Service B
2009 Mercedes-Benz G55 AMG in New York, NY
$325 - $625
Brake Pad and Rotor Replacement
2005 Mercedes-Benz G55 AMG in North Miami Beach, FL
$431 - $557
Brake Pad and Rotor Replacement
2005 Mercedes-Benz G55 AMG in North Miami Beach, FL
$454 - $698

Most Common Mercedes-Benz Repair Estimates

Door Window Regulator Replacement
$480 - $595
Brake Pad and Rotor Replacement
$473 - $722
Oil and Filter Change
$69 - $119
Ball Joint Replacement - Lower
$232 - $390
Spark Plug Replacement
$453 - $554