2010 Lincoln Navigator Repair and Maintenance

A guide to problems, costs, maintenance and repair for your 2010 Lincoln Navigator

Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
Get a Repair Estimate For Your 2010 Lincoln Navigator
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more

2010 Lincoln Navigator Problems

Rough Idle and/or Engine Stalling Condition

In high dust areas, problems with the EGR system are common. The filter for the EGR solenoid may plug and cause the EGR to activate when it should not; this can cause the engine to stall. The dirty filter should be replaced to correct this concern.

A/C Fan Speed Changing Constantly

The Lincoln Navigator with optional automatic temperature control may have a problem with frequent fan speed changes when using the heater or air conditioner. Normally, the fan speed changes only to maintain a selected temperature, but when the fan speed changes frequently and needlessly, there is an issue with the fan speed control unit. 

The fan speed control unit, sometimes erroneously called the blower motor resister, regulates the speed for the blower motor in order to maintain the temperature set by the driver. When it fails, the fan will run at random settings, and the climate control will be inaccurate.

Note: this does not affect the temperature of the air that comes from the vents, it affects the amount of air that comes from the vents. 

The repair is simple, and quick. The control unit is located behind the glove box in most models, and removal and installation takes only minutes.

Also note: this only applies to vehicles with single or dual automatic climate control.

Blower Motor Only Works on High

The 2008-2014 Lincoln Navigator and Navigator L with manual temperature and fan controls may have problems with the the blower motor only blowing air on certain settings. Most commonly the fan will only run on the highest setting. This is a well documented problem, and is caused by a failing blower motor resistor.

Correcting the problem is straight forward, and requires replacement of the small resistor. The resistor is normally found behind the glove box, next to the blower motor.

See More Problems (13)

2010 Lincoln Navigator Questions

flat tire - jacked and messed up running boards? (1 answer)

Turn off suspension switch before jacking/lifting vehicle with air suspension, but I didnt, now how do I fix running boards not coming down and uneven

See More Questions (2)