» » » 1992

Resources for the Repair and Maintenance of your 1992 Ford Aerostar

1992 Ford Aerostar

Image for car images Ford 1992 1997 Ford Aerostar size thumb

1992 Ford Aerostar Problems

Engine -- Verified

Engine oil leaks are known to develop around the rear crankshaft (main) seal and engine oil pan gasket.

Exhaust & Emissions -- Verified

If you experience poor idle quality and fuel economy (and the Check Engine Light illuminates) after the exhaust system or motor has been removed and replaced, it could be that the oxygen sensor wires are crossed at the rear of the motor. Wiring schematics should be checked to ensure that the correct harness plug is connected to the corresponding sensor.
 

Engine -- Verified

The valve cover gasket may fail, causing engine oil to leak onto the exhaust manifolds.

Engine -- Verified

An engine knocking noise coming from the lower end during acceleration is common and could be caused by worn or damaged engine bearings.

Heating & Air Conditioning -- Verified

The AC system may be performing poorly even if it seems to be functioning properly. This could be caused by the AC air blend door being out of adjustment.

1992 Ford Aerostar Recalls (Recent)

Brakes, April 15, 1998

Summary: EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.

Learn more »

Drive Train, February 16, 1998

Summary: VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.

Learn more »

Drive Train, June 17, 1999

Summary: VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. (THIS INCLUDES ALL 1992 AWD AEROSTARS NOT PREVIOUSLY INCLUDED IN SAFETY RECALL 97V-204/97S83). THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.

Learn more »

Electrical & Lights, March 19, 1999

Summary: VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.

Learn more »

1992 Ford Aerostar Questions and Answers

netdoc, 1992 Ford Aerostar, 4.0L V6, Flippin, AR

Car will start but not idle and cooling fan comes on as soon as I start the car.

heibv, 1992 Ford Aerostar, 3.0L V6, Farnsworth, TX

how to fix?

Visitor, 1992 Ford Aerostar, 3.0L V6, Keyport, NJ

anyway to buy a little time with a slight weephole drip

Visitor, 1992 Ford Aerostar, 3.0L V6, Keyport, NJ

exactly which parts, do I have to remove for access to change the pump, the clymer and chilton manuals have a couple of differences,and can i do it from standing in the front,or do i need bottom ac...

Visitor, 1992 Ford Aerostar, 3.0L V6, Keyport, NJ

hi Roy, are you saying i can leave the radiator in , or remove for better access?

Write a Review About Your Car

1992 Ford Aerostar Reviews

a/c fan not working --on heat it works-- and on outside it works --what is wrong--?

I an the only owner-- igot it brand new -- i had the a/c and compresor rebilt after 12 yrs-- I got 86000mils- thank you margaret A

brakeline rusted shifter solenoid broke, shifter broke, exaust fell off makes a loud klunk when shifting into reverse, whines when you get above 20 mphs calls for 215-70r-14 tires, which are not very common a rust problem at base of doors. Problem with air conditioner hoses (leaks). just bought it and hope to be pleased with it once I put some work and money in it. has 107,000 miles on it other than the rear end needing work I happy with my purchase of it at $600.00

Recent Repair Estimates